Professional Documents
Culture Documents
MAKITA CORPORATION
ISSUED June 08, 2011
Techno Service Section
Quality Assurance Dept.
DRAWN NO. MWSN-135 Technical Div.
General Manager N. Takeuchi
Compatibility of the cylinder liner Dept. Manager K. Kubo
Section Chief N. Inoue
Drawn By Y. Fukuoka
ENGINE TYPE S42MC (with mechanical lubricator)
Dear Sirs,
We would like to inform about the compatibility of the cylinder liner.
There are two kinds of the cylinder liner for the S42MC type engine, design for mechanical
lubricator and alpha lubricator.
Hereafter, we will supply the cylinder liner which is designed as the alpha lubricator because the
cylinder liner design for alpha lubricator has the compatibility of design for mechanical lubricator.
When install the alpha type liner to the mechanical lubricator engine, it is necessary to install with
Non return valve and Pipe joint with gasket.
They will be supplied with the alpha type liner.
CYLINDR LINER
Mechanical type Alpha type
TYPE
whole area Around the injection hole only
55 degree 45 degree
b) Angle of
the non-return valve
Flange type
Screw type
c) Non-return valve
and
Pipe joint with
gasket
*****************************
MAKITA SERVICE NOTE
*****************************
2. Installation2 “Non return valve”
When fix the “Non return valve” on the liner, to be measured the depth according to the drawing.
Cylinder liner
3. Installation 3 “Piping
Due to the different angle of the “Non return vale” it is necessary to have slight modification of the
piping as below pictures. The position of the “Non return valve” is estimate 50mm shifted clockwise.
Therefore, to fit the tip of blanch pipes, it is necessary to bend the pipe slightly.