Professional Documents
Culture Documents
(VoHI) X Edition
4. Path of insertion and removal of an RPD is determined by guide planes and
PROSTHODONTICS AND CRoWN AND a)minor connector b) occlusal rest
BRIDGE- MCQ's PAPER c)major connector dclasp
5. Squint test is used in complete denture prosthodontics f o r / t t
Dental Diaries
SUMMER - 2013
On Telegram a) Orientation relation
b)Finding out parallelism of ridges
cSelecting proper shade of teeth
Total Duration d) Marking canine lines
: Section A + B+C =3 Hours Section A Marks 20
6. Extra retention in abutment in an FPD is obtained by
SECTION - A a) Dove-tail preparation bSlots and grooves
d) Increasing tooth reduction
Instructions: ) Fill (dark) the appropriate empty circle below the
cOutlineform
question mumber once only. 7. Gingival retraction with mechano-chemical method provides
2) Use blue / black ball
point pen only adisplacing the gingival tissues laterally away from the tooth
3) Each question carries one mark. b) displacing the gingival tissues apically
T
Chapterwlse Distrlbution of University Questions I B.D.S. (VoHI) XP Edition
Chapterwise Distribution of University Questions I B.D.S. (VolHI) XT Edition
2. The mean denture bearing area in the edentulous mandible (in cm) is
15. Veau's classification is given for
approximately :
a) cleft palate c l e f t palate and lip b) 1625
a12.25
c)mandibulectomy d) maxillectomy 18.12 d) 20.25
c)
16. Which of the following major connectors has maximum ngidity ?
3. Anterior vibrating line is located
a) palatal bar b) horse shoe shaped palatal plate
a)On hard palate
c)palatal strap dantero-posterior palatal strap DAt the junction of hard and soft palate
17. The use of tissue conditioner is indicated in following cases EXCEPT On soft palate
a) g e resorption b)bruxism d) At the junction of muscularis uvulae and palatine muscle
exerostomia d) after alveolar surgery 4. True hinge axis is located with the help of
18. The material not used for border moulding a) Ear rods b) Maxillomandibular vertical relation
a) low fusing impression
compound Kinematic face bow d) Orbital pointer
b)medium fusing impression compound Modiolus at the corner of the mouth is formed by all of the following
c)addition silicone putty consistency muscles EXCEPT:
alginate hydrocolloid a Triangularis b) Buccinator
19. The occlusal rest is the thickest in d) Orbicularis oris
cross section in the Masseter
a) marginal ridge area Ratio of width of the central incisor to the bi-zygomatic width is
6.
b) central fossa a) 1:2 b)14
midway between the marginal ridge and central fossa 1:8 d 1:116
c)
d) equal in dimension in all areas
7 During relining procedure, special care should be taken to prevent alterati on
20. The finish line used in full ceramic of
crown is
a)knife edge b) chamfer 2) Balanced occlusion bCentrnicrelation
radial shoulder d) feather edge Vertical dimension d Centric occlusion
SPACE FOR ROUGH WORK Functional cusp bevel is given for
a) marginal integrity b)structural durability
c) retention form d) resistance formn
SUMMER (PHASE I1) 2019 -
. Antes law is an aid for
a) Selection of pontic b) Selection of connector
Total Duration
:Section A+B +C =3 Hours c) Selection of retainer Selection of abutment
Section A Marks: 20
SECTION - A 10. The finish line of choice in complete metal cast crown is
a) chamfer chamfer with bevel
(MCO) c) feather edge d)shoulder
1. The stability of a (20x1-20)
mandibular complete denture will be 11, The reciprocal am
of a clasp assembly should always be
a) Level of oclusal enhanced when :
plane is above the dorsum of a) On lingual side
bTongue rests on the occlusal
surface
tongue
b) Active
c) Lingual contuor of the denture is concave Passive
dPosteriorteeth the denture have a
on
broad d) Active when half he denture is inserted
buccolingual width
194) 195)
B.D.S. (Vo-H) XIh Editlon
Chapterwise Distribution of University Questions IVh
-
12. The main disadvantage of metal ceramic restoration as compared to porcelain
jacket crown is
a) Less strength Poor color matching
c) More porous d) Less retentive
13. Which of the following is NOT a property of dental ceramic restorations ?
a) They are highly color stable
b) They are highly resistant to surface abrasion
c) They usually have high translucency
dThey are highly malleable materials at room temperature
14. Flux js used during casting to:
Remove the oxides formed on the gold alloys
b) Lower the melting point
c)Replacecasting wax
d) Speed the burnout process
15. Distal extension Removable Partial Denture is :
Both tissue and tooth borne b) Tooth borne
C) Tissue bome d) None of the above
16. Unilateral edentulous area with natural teeth present both anterior and
posterior to it represent
a) Sennedy's Class I b) Kennedy's Class II
Kennedy's Class II d) Kennedy's Class IV
17. Which of the following is NOT mandibular
a
major connector
a) Lingual plate b) Lingual bar
Lingual arch d) Labial bar
18. Distance between maxillary
major connector and tooth-tissue junction should
beatleast
a) 2 mm
b) 4 mm
6 mm d) 8 mm
19. Clasp assembly should encircle at least how much of the
a) 120 degrees abutment tooth ?
b) 160 degrees
180 degrees ( d 360 degrees
20. Krnbll designed
RPIRPI clasp b) bar clasp
c)circumferencial clasp d) altered clasp
SPACE FOR ROUGH WORK
196)