You are on page 1of 1

Search...

HOME COMPANY PRODUCTS SUPPORT & SERVICE DISTRIBUTION CONTACT

Home › Products for Marine and Industry › Protection and Control Relays › Auto Synchronizer T4500 for Conventional Governors

SELCO Auto Synchronizer T4500 for


Products Conventional Governors
The Auto Synchronizer T4500 for Conventional Governors provides auto‐
Alarm Monitoring and Indicator Panels
matic synchronization of an incoming generator to a busbar in a minimum
Engine Controllers
of time, by controlling the speed via the electric servomotor on a conven‐
Generator Controllers
tional speed governor, or by controlling an electronic speed controller via
Protection and Control Relays
an intermediate motorized potentiometer.
Reverse Power Relay T2000
Excitation Loss Relay T2100 Send an Enquiry
Overcurrent Relay T2200
Short Circuit Relay T2300
Dual Overcurrent Relay T2400 Description
Overcurrent & Short Circuit Relay
T2500
Dual Current Relay T2600
Overload Relay T2700
The T4500 Auto Synchronizer for Conventional Governors
Overcurrent or Earth Fault Relay T2800
The SELCO T4500 Auto-Synchroniser provides automatic synchronisation and connection of a generator to a
Differential Current Relay T2900
live bus bar.
Frequency Relay T3000
Voltage Relay T3100 The T4500 measures the voltage across two phases on either side of the circuit breaker in order to obtain data
Insulation Monitoring Relay T3200 on frequency, phase and voltage deviation.
Voltage Relay (3-Phase) T3300
The T4500 will automatically adjust the speed of the generator (through the governor) in order to match the fre‐
Frequency Deviation Relay T3500
quency and phase to the live busbar. Two built-in relays provide the increase and decrease pulses for a conven‐
Auto Synchronizer T4000
tional governor. The strength (width) of the pulses is proportional to the frequency/phase deviation. The E7800
Load Sharer T4400 for Electronic
Speed Controller Motorised Potentiometer can be used to adapt the contact pulses to a signal suitable for the speed trim input of
Auto Synchronizer T4500 for an electronic speed controller.
Conventional Governors
The T4500 will continuously adjust the generator speed until frequency and phase is within limits. The signal to
Load Sharer T4800 for Conventional
Governors close the circuit breaker is issued just before phase accordance is obtained. This is done in order to compensate
VAr Load Sharer T4900 for the circuit breaker make time.
Motorized Potentiometer E7800
Synchroscope M8100
Paralleling Relay T5000
Electronic Potentiometer T7900 Features:
Blackout Limiter T8400 Automatic synchronisation
Automatic voltage matching
Power Relay G2000
Relay based speed control
Current Relay G2200
Adjustable breaker make time
Frequency Relay G3000
50 hour burn-in before test
Voltage Relay G3100
Certified for marine use
Voltage Relay G3300
Voltage Relay G3600
Accessories
Click here to find your local distributor
Arc Flash Detection
Service & Spare parts

Downloads
Data

Certificates

Catalogue

Contact Get Connected


SELCO ApS Phone: +45 70 26 11 22 Contact us
Betonvej 11 E-mail: selco@selco.com Find distributors
DK-4000 Roskilde
Denmark
V.A.T No.: DK-37 42 76 75

© SELCO 2022 All rights reserved

You might also like