Professional Documents
Culture Documents
www.gantrex.com
GANTREX Group – info@gantrex.com
RailLok™ Series
Installation and Suggested Weld Instructions - W10, W15 & W17
1. Position clip lower with gap ”A” as shown 2. Weld ensuring that the clip lower does not lift.
and tack weld in place.
Suggested electrodes
«*» indicates the position of evacuation holes for zinc when galvanizing sole plates Use any low hydrogen rod suitable for use with struc-
tural steel :
ISO2560 type E 42 5 B 32 H5, E7018 or equivalent.
INSTALLATION RECOMMENDATIONS
The centerline of the rail must be used as the reference. Using gages is recommended.
Clips should be installed in opposing pairs. They should never be staggered.
Welding should be completed prior to pad installation, as excessive heat could damage the pad.
Do not paint between clip components unless accepted by Gantrex.
Clip spacing, distance of weld to the edge of the steel plate, as well as corrosion protection will depend on the application.
Please consult Gantrex.
www.gantrex.com
GANTREX Group – info@gantrex.com
RailLok™ Series
Installation and Suggested Weld Instructions - W10, W15 & W17
1. Install the bolt heads in the clip lowers and 2. Install the clip upper part, and push it against the rail.
push as far as possible.
3. Install the nuts and finger tight 4. Once the clip upper part is in position, use an impact
(the washer is integrated in the nut). wrench to torque the nut, while holding the upper in place.
NEW FEATURES
The patented self-contact design of inclined bolt ensures upper component remains in contact with rail foot during installation process.
Hitting the clip upper part with a hammer is not required anymore.
Due to the special “Square Shank Base” screw head, electrical and pneumatic torque wrench is allowed and will not damage the screw.
To be sure the right torque is achieved; regular control during installation with a calibrated torque wrench is recommended.
TORQUES
Verification of the required hardware torque and clip adjustment should be performed within the first three months after operating start-up.
www.gantrex.com
GANTREX Group – info@gantrex.com
RailLok™ Series
Installation and Suggested Weld Instructions - W10, W15 & W17
CLIP COMPONENTS
1 x W10/22N
or 1 x W10/25N
or 1 x W10/30N
Full designation
RailLok™ W15
W15/AN
or W15/BN
or W15/CN
or W15/DN
Components
1x Sp M16 Cl8 GAL
1 x W15/28N
or 1 x W15/29N
or 1 x W15/35N
or 1 x W15/39N
RailLok™ W17
Full designation
W17/AN
or W17/CN
Components
1x Sp M16 Cl8 GAL
1 x W17/30N
or 1 x W17/34N
1 x SSB M16x35 8.8 GAL
1 x W17/25
COMPONENT MATERIAL
We reserve the right to discontinue or change specifications or design at any time without prior notice and without
incurring any obligation whatsoever.
GXHQ-EN 2018-02 R2.1
www.gantrex.com
GANTREX Group – info@gantrex.com