Professional Documents
Culture Documents
Application areas:
Operating instruction
Remove dust, impurities and grease from working surfaces. Shake the bottle, screw on the
gun and put on a special nozzle (included in the kit) on its tip. Open the gun’s valve as much
as possible. Spray on the material to be bonded or on the working surface from a distance of
30 to 40 cm, fully pressing the gun’s trigger. Wait for 5 minutes. Firmly press the material to
be bonded with the surface. The time for correction is up to 5 minutes. The time of
polymerisation is up to 20 minutes. Operating environment temperature: -5°C to +35°C.
Recommended operating temperature of the bottle: +18°C to +25°C. Full curing within 24 h.
Technical data:
* These values were obtained at the temperature of -5°C to +30°C and the relative humidity
of 40 to 60%
Storage conditions:
Transport and store in vertical position, in a dry place, at the temperature of +5°C to +30°C.
Shelf life: 18 months. Keep the bottles with thermal-insulation spray adhesive away from
direct sunlight and heat exceeding 50°C.
Safety measures
Contains 4,4' diphenylmethane diisocyanate. Irritates mucous membranes, upper respiratory
tract and skin. Inhalation may cause allergy. In case of eyes contact, rinse well with water
and seek medical advice. Do not smoke while working! Keep away from children. Do not store
the bottles at temperatures higher than +50°C and in direct sunlight. Detailed safety
information is provided in safety data sheets.