1910872028, 23:57 Basie Cisco MDS configuration —_Das Blinken Lichten
Basic Cisco MDS configuration
AAs | laid out in my last post, these are the basic steps for the SAN configuration of a Cisco MDS series switch. They are.
1. Create the VSAN number you wish to use (1 is the default, not recommended to use the default for production SAN
traffic)
‘Add interfaces to your VSAN (ust ike you do with a VLAN)
Do any interface configuration needed on the FC interfaces (Just turn them on in most cases)
Verify the cabling and ensure that you have SAN connectivity
Create Aliases for WWNs (makes life easier)
2
3
4
5
6. Create required zones
7. Add members to your zones (I recommend using PWWNs)
8, Create a zoneset (I think Brocade calls this a ‘contig’)
9, Add your zones to your zoneset
10, Activate the zoneset on the fabric
So lets walk through them one at a time and show the associated configuration. ll use my same old color coding
conventions,
“Insert your relevant information between <>
Console prompts are shown in green
1.Create the VSAN number you wish to use (1 is the default, not recommended to
use the default for production SAN traffic)
MDS{(config)# vsan database
MDS(config-vsan-db}# vsan
MDS\(config-vsan-db}# vsan name
MDS(config-vsan-dbyi exit
-Add interfaces to your VSAN (just like you do with a VLAN)
MDS(config)# vsan database
MDS (config-vsan-db}#! vsan
MDS(config-vsan-db}# vsan interface
MOS (config-vsan-db}# exit
\wvw.dasblinkenichten.com/basle-csco-mds-configuration! 421910872028, 23:57 Basie Cisco MDS configuration —_Das Blinken Lichten
-Do any interface configuration needed on the FC interfaces
MDS{(config}# interface
MDS{(config-if# no shutdown
MDS{(config-if}# switchport mode
MDS(config-if# exit
-Verify the cabling and ensure that you have SAN connectivity
Your on your own here. As with anything fiber, if you don't have link, make sure you have the pair fipped correctly from
SFP to SFP.
-Create Aliases for WWNs (makes life easier)
MDS(config# calias name vsan
MDS(config-fcalias}# member pwwn
MDS(config-fealias)# exit
Create required zones and add members
MDS(config)# zone name vsan
MDS(config-zone)# member fealias
MDS(config-zone}# member fcalias
MDS(config-zone}# exit
(roto: you didnt want te make aliases, you could use the keyword puwn'rathor than Yeas’ and decty nput the WH)
-Create a zoneset (I think Brocade calls this a ‘config’) and add the zones to the
zoneset.
MDS{(config}# zoneset name vsan
MDS(config-zoneset}# member
MDS(config-zoneset}#t member
MDS{(config-zoneset}# exit
-Activate the zoneset on the fabric
MDS{(config)# zoneset activate name vsan
Conclusion
And that's it. It goes without saying, but save your config when you are done.
\wvw.dasblinkenichten.com/basle-csco-mds-configuration! 22