Professional Documents
Culture Documents
GENERAL INSTRUCTIONS
LIST OF PROJECTS
1. Design a simplified circuit from a circuit (which consists of two independent sources) which gives
the maximum power to the load.
2. Design a simplified circuit from a given circuit (which consists of two independent sources)
which provides the same value of power to the load.
3. Design a circuit that would give a voltage output which is two third the input.
4. Design a circuit with two voltage sources and one current source which combined will give
100V across a load resistance.
5. Design a circuit which, when connected in parallel with a branch, would limit the current
through that branch by a factor of 0.5.
6. Design a circuit with three voltage sources which combined will give 100V across a load
resistance.
7. Design a circuit with four nodes (excluding ground node) and show that KCL has been
conserved in each of the four nodes.
8. Design a circuit with three loops and show that KVL has been conserved in each of the three
loops.
9. Design a series circuit with 5 resistance in which voltage drop decreases progressively by
15% in each of the resistance connected in series.
10. Design a parallel circuit with three resistive branches that would have one fifth of the input
current to one of the branches.
INSTRUCTIONS FOR THE PROJECT
The project has to be done by any of the software used for simulations of electrical circuits.
The software file needs to be submitted within due time.
Anyone willing to convert the simulation into a hardware setup has the freedom to do it.
Preferred software: PSIM, Proteus, PSpice, Simulink.