Professional Documents
Culture Documents
1 Technical Specifications
1 Technical Specifications
Technical Specifications 1
1 Technical Specifications
a
AUTOLITH TP
Technical Specifications 1
1 Technical Specifications
Topic See ..
What is in this Chapter Page 1
General Specifications Page 2
The Installation Site Page 3
Power Page 4
Printing Page 6
Water Connections / Information Page 7
a
AUTOLITH TP
1 Technical Specifications
Size
The table below lists the dimensions of the AUTOLITH TP:
TP 85 TP 105
Width 1462 mm 1662 mm
Height (Typical) 1100 mm 1100 mm
Length without input and output 1202 mm 1202 mm
table
Length with input and output table 2692 mm 2692 mm
Processing length 2326 mm 2326 mm
Width 610mm
Height 257mm
Length 390mm
Weight The table below lists the weight of the AUTOLITH TP:
TP 85 TP 105
Without packaging 368kg 393kg
With packaging 501kg 537kg
Empty 25.4kg
Full 38.4kg
a
AUTOLITH TP
Technical Specifications 1
November
April 2001 2000 Page 4
Data & Timings The data and timings on page 3 are based on a plate length of
1m.
Noise generation
The average noise generated by the AUTOLITH TP Processor
amounts to <73 db(A).
Noise measurement is in accordance with DIN 45635 T27 at the
position of the operator.
a
AUTOLITH TP
1 Technical Specifications
Temperature and Relative To ensure the reliable operation of the processor, the relative
Humidity humidity (RH) and the ambient temperature (T) in the room must
fulfil the following diagram:
85%
60%
15%
Room ventilation
10 x room volume / hour
Room ventilation according to “Hazards and their prevention”;
ILO-Standard, Volume II, p. 1057, Photographic processing.
a
AUTOLITH TP
Technical Specifications 1
November
April 2001 2000 Page 6
1.4 Power
Power supply The power supply requirements for the AUTOLITH TP are:
Frequency Phase Voltage Current *
50 Hz 1~ 230 V (+ 10%) 16 A
50 Hz 3~ 230 V (+ 10%) 12 A
50 Hz 3N~ 400 V (+ 10%) 9A
60 Hz 1~ 240 V (+6% - 10%) 16 A
60 Hz 3~ 208 V (+6% - 10%) 12 A
Initially 2500 BTU’s falling off to 1300 BTU’s after 30 minutes, then
reducing to approximately 500 BTU’s. These figures are per hour.
a
AUTOLITH TP
1 Technical Specifications
CE
Power consumption Power consumption of the AUTOLITH TP is:
Electrical connection The AUTOLITH TP has been provided with both an On-line Static
to imagers Interface (OSI) enabling synchronization and in-line connection
with other devices, such as imagers.
a
AUTOLITH TP
Technical Specifications 1
November
April 2001 2000 Page 8
Agfa offers a wide variety of printing plate sizes and printing plate
correctors suitable for use with the AUTOLITH TP . Please ask for
more information.
Water supply
The water supply must conform to the following specifications:
a
AUTOLITH TP
1 Technical Specifications
The table below lists all pages in Technical Specifications with their
Edition
edition :