Professional Documents
Culture Documents
Makelodev
Makelodev
1) A system is loaded as shown in the figure below. Points A and C are bearing locations. Shaft is made of
a steel having Sy: 5AB MPa and Sut: 6BA MPa. (All dimensions are in mm, D/d is 1.1 and fillet radius are 3
mm.)
a) Evaluate the total forces, moments and torques acting onto the system.
b) Design the shaft based on a factor of safety of A,B for 90 percent reliability and infinite life. The shaft is
machined surface.
(In the question A and B is the last two digits of your student number, respectively. If A and/or B is equal
to zero assume them 1.)
NOTE ! State all the assumptions that you make in design process in the assignment.
NOT! Tasarım prosesinde gerekli gördüğünüz tüm kabulleri projede belirtiniz.