Professional Documents
Culture Documents
Wing sweep
Make 2 from 1/4" hard
0.19"
0.58" 0.61"
Right wing Left wing
Mak
Upp 2 from
Mak
L o w 2 f ro m
e
er w
e
er w
1
wing ply
1
wing ply
a rm
a rm
Temporary Temporary
Inlet Inlet
Bulkhead 1 Bulkhead 2
Vertical tail root fairing - Make 4 Rudder control horns
(make 2 from 1/32" plywood)
Make 1 Make 1
Wing swing arm spacer
(make 4 from 1/8" lite-ply,
laminate to make 2 pairs)
(0.5" x 1.0")
Install spacer
spacer here
Make 4 from 1/8" lite-ply
Wing sweep spar box
tongue doublers
Inlet bottoms
Make 2
(1.0" x 1.87")
Lite-ply doubler
tray spacer
underneath
Stabilator
Make 2
Vertical tail
Make 2
Temporary
Inlet
Bulkhead 3
Make 1
Install 3/
Install 3/8
doubler
Make 1
Make 1
F-1 F-2
Make 1 Make 1
2
un Pod
Scale in inches
0 2
Wing panel
Make 2
Aft wing cover Cut acce
Make 1
Cut hole to access
wing swing servo
Strake/inlet top
Center support for aft wing cover
Make 1
Make 2 and laminate
Install fwd f
Nose cone
Make 12 and laminate F-1
with 3M 77 spray
Canopy
Make 10 and laminate
with 3M 77 spray
Turtledeck sides
l - Make 2 Make 2
Canopy sil Cut top and bottom edges at a roughly 15 degr
re
se doubler he
nstall fwd fu
strip here
Install 2 layers of 3/8" foam
Fwd fuselage doubler
Make 2
If you enjoy th
to the design
Turtledeck top into develop
(trim to fit) be sent via P
Make 2
Designed by Steve Shumate
Copyright © 2005 All Rights Reserved
All parts are made from 6 mm Depron or
BlueCore foam unless otherwise specified
enjoy these plans, please consider sending a small contribution
e designer to show your appreciation for all the work that went
developing them. Suggested contribution is $10 U.S., and can
nt via PayPal to jetset44@verizon.net. Thanks for your support!