Professional Documents
Culture Documents
Install spacer
spacer here
Mak
Upp 2 from
Mak
Low 2 from
swin
1
swin
1
g a r ly
g a r ly
m
p
m
p
Inlet
Bulkhead 1 Bulkh
- Make 4 Rudder control horns
(make 2 from 1/32" plywood) Make 1 Ma
spacer
" lite-ply,
2 pairs)
Inlet
Bulkhead 2
Make 1
(1.0" x 1.87")
Lite-ply doubler
tray spacer
underneath
0.25"
0.78" 0.81"
Right wing Left wing
Vertical tail
Make 2
Temporary
Inlet
Bulkhead 3
Make 1
Temporary Tem
Inlet
Cut slots to accept tabs
on center fuselage bottom
Temporary
Inlet
Install 3/8" foam strips here
Inlet bottoms
Make 2
t slot to fit
otor mount
Motor mount Motor mount
Middle piece Top piece
Make 2 Make 2
Wing panel
Make 2
Stabilator
Make 2
Aft wing cover
center piece
Make 1
top
Center a
Fwd strake bottom piece
Make 2
doubler
Make 1
Make 1
F-1 F-2
Make 1
Make 1
strip here
Install 2 layers of 3/8" foam
F-3
Make 1 4
Scale
0
Turtledeck top
(trim to fit)
Make 2
Strake/inlet top
Center support for aft w
Make 1 Make 2 and lamin
cale in inches
2 4
be sent via PayPal to jetset44@verizon.net. Thanks for
Inlet diverter
Make 2
e re
se doubler h
Install fwd fu
Canopy
Make 10 and laminate
with 3M 77 spray
Turtledeck sides
l - Make 2 Make 2
Can op y sil Cut top and bottom edges a
Turtledeck top
(trim to fit)
Designed by Steve Shuma
Copyright © 2005 All Rights Rese
All parts are made from 6 mm Depron
BlueCore foam unless otherwise speci
If you enjoy these plans, please consider sending a smal
to the designer to show your appreciation for all the wo
into developing them. Suggested contribution is $10 U
be sent via PayPal to jetset44@verizon.net. Thanks for
mate
Reserved
pron or
pecified
small contribution
he work that went
$10 U.S., and can
s for your support!