Professional Documents
Culture Documents
TECHNICAL DRAWING
Paper 02 - General Proficiency
lt hours
GENERAL INFORMATION
3. When first-angle or third-angle is not specified, the choice of projection is left to the
candidate's discretion, in which case the type of projection used MUST be clearly stated.
4. Where scales to be employed are not stated, the full size should be applied.
7. The number of each question answered MUST be written next to the solution.
8. Each candidate MUST enter his/her school code and registration number in the appropriate
space at the bottom right-hand corner of the drawing paper.
- 2 -
This paper has TWO sections: Section I, Plane Geometry and Section II, Solid Geometry.
Answer FOUR questions, TWO from Section I (Plane Geometry) and TWO from Section II (Solid
Geometry).
1. (a) Draw a line AB, 95 mm long. Divide AB into seven equal parts.
(b) Construct a rectangle with sides equal to ~ and ~ of AB, given in (a) above.
(20marks)
2. Figure 1 shows the trademark of a car manufacturing company. The trademark shows four equal
circles inscribed in the larger circle. Show the construction procedure for obtaining such a design.
0100
Figure 1
(20marks)
3. Using the focus method, draw the curve of a hyperbola with the eccentricity of 5:3. The distance
from its vertex to its focal point is 25 mm and from vertex to directrix is 15 mm.
(20 marks)
4. Figure 2 shows the line ABC at an angle of 45° to the horizontal at B and a circle, centre O, touching
the line ABC at point P.
V i circumference
DIM. IN MM
Figure 2
(b) Plot the locus of point P when the circle, centre O, makes one complete revolution along
the line ABC. (20 marks)
5. Figure 3 shows a plan and elevation of a right square pyramid cut by a plane DD at 60° to the
horizontal.
ELEVATION
DIM. IN MM
PLAN
Figure 3
6. Figure 4 shows two orthographic views of a machined block and a reference line XY at 45° to the
horizontal.
ELEVATION
PLAN
Figure 4
2 HOLES
0 8X15
DEEP
RIO
DIM. IN MM
Figure 5
Using the cabinet or cavalier method, draw an oblique projection of the block.
8 . A right-hand helical spring is made from a steel bar having a circular cross-section with diameter
10 mm. The outside diameter of the spring is 70 mm. The pitch of the coils is 50 mm.
END OF TEST
01247020/F 2006