Professional Documents
Culture Documents
a. The datum plane (DP) is a plane which is along the airplanes longitudinal axis
and in front of the airplane as seen from the direction of flight
c. The datum plane is located 2.196meters (86.46 in) forward of the most
forward point of the root rib on the stub wing
a. 105 KIAS
b. 95 KIAS
c. 90 KIAS
d. 100 KIAS
4. Maximum CHT
a. 500 C
b. 260 C
c. 245 C
d. 230 C
a. 57 KIAS
b. 64 KIAS
c. 52 KIAS
d. 63 KIAS
b. 64 KIAS
c. 52 KIAS
d. 63 KIAS
a. 2700
b. 2400
c. 2680
d. 2300
8. VNAV information
a. Is accurate information
a. The primary altitude reference during all operations using advisory vertical
navigation(NAV) information and the autopilot
DGCA DA42 EXAM PAPER
b. A flight altitude selected via the autopilot must be verified and corrected
according to the indication of the calibrated altimeter
c. The barometer correction and the altitude preselect are not synchronized
between Garmin and Bendix/King Units.
13. Reduce airspeed below _______ and apply moderate yawing and pitching to assist in
bringing the landing gear into the locked position
a. 100 KIAS
b. 110 KIAS
c. 120 KIAS
d. 155 KIAS
14. If the oil pressure has not moved in green sector after starting
c. Proceed normally
b. 95 Psi
c. 105 Psi
d. 115 Psi
b. GIA is inoperative
a. 30 Kg
b. 10 Kg
c. 45 Kg
d. 18 Kg
a. 16000
b. 18000
c. 19000
d. 20000
a. 1
b. 2
c. 3
d. 0
22. For each 4 knots of head winds, the takeoff distance decreases by ___%
a. 2
b. 3
c. 4
d. 5
23. What is the Blue band Best rate of climb speed, single engine of the DA42
a. 80 KIAS
b. 100 KIAS
c. 90 KIAS
d. 70 KIAS
24. To check cross feed the engines should be run for a minimum of ……..secs.
a. 20 seconds
b. 25 seconds
c. 30 seconds
d. 35 seconds
25. What is the Red band Minimum control speed, single engine of DA42
a. 55 KIAS
b. 60 KIAS
c. 65 KIAS
d. 70 KIAS
26. DA42 Max CHT:
a. 500 degrees F
b. 260 degrees F
c. 500 degrees C
d. 250 degrees C
27. What is the max speed that the landing gear wheels can be subjected to:
a. 110 mph
b. 120 mph
c. 178 mph
d. 90 mph
28. The minimum and maximum oil quantity
a. 05 -10 Secs
b. 05 -20 Secs
c. 15 -30 Secs
d. 10 -30 Secs
30. The manual extension of the landing gear can take _____ secs
a. 15
b. 20
c. 25
d. 30
32. Incase of strong winds, wind shear and turbulence the airspeed for approach should be
a. Higher
b. Lower
c. Correct
d. None
33. The Total fuel capacity of the main tanks of DA42 in gallons is
a. 26x2
b. 20x2
c. 23x2
d. 21x2
34. The Maximum Take-off Weight of DA42 is
a. 3935
b. 3500
c. 3400
d. 4500
DGCA DA42 EXAM PAPER
35. The variable pitch propeller is controlled by
a. Oil pressure
b. Hydraulic pressure
c. Air Pressure
d. Spring Pressure
36. To get best power mixture the EGT should be …………deg F lower than best economy.
a. 75 Deg F lower
b. 90 Deg F lower
c. 100 Deg F lower
d. 110 Deg F lower
37. In strong crosswinds use ………….to augment steering during take off.
a. Ailerons
b. Nose wheel steer
c. Toe brakes
38. What is the maximum landing gear retraction speed of DA42
a. 156 KIAS
b. 182 KIAS
c. 194 KIAS
d. 164 KIAS
39. The Maximum Emergency Gear Extension speed is
a. 166 KIAS
b. 182 KIAS
c. 156 KIAS
d. 164 KIAS
40. If oil temperature indication is high and CHT and EGT is normal then it is a
a. An oil temperature indication fault
b. An oil temperature probe fault
c. An actual oil pressure failure
d. none of the above