Professional Documents
Culture Documents
1D
2000.1DEVO
EVO
Owner's Manual
English
INTRODUCTION
1
PANELS DESCRIPTION
1 2 3 4 5 6 7 8 9 10
9 11 12 13
14
15
16
2
PANELS DESCRIPTION
J. Anflor Eletrônicos - ME
Gravataí - RS
Brazil
- EN 60065:2002+A1:2002+A11:2008+A2:2010+A12:2010
- IEC 60065:2014-06
Juliano Anflor
J. Anflor Eletrônicos
Brazil
3
INSTALLATION
4
INSTALLATION
500A
OUTPUT
Output for additional
amplifier
To avoid unwanted noise in the system, join the Gain positioning over the correct
ground points of the equipment and audio output to spot may cause noise, trigger
only one point. protection state or damage to the
Warning! speakers.
After the end of the electrical installation, connect
the negative cable of the battery and, before starting
the audio system, check if all connections are If you have any doubts, talk to the speaker's
correctly done.
manufacture.
The selection key only defines the low pass filter.
In order to adjust the gain, use the headunit volume
in 70% of its total, play a musical program of your The high pass filter is always in action, regardless
preference and turn up the gain until the clip led the key position. (Unless it is in the "mute" position).
blinks. Set the gain in a position where the “CLIP’’
LED doesn't blink. If you need to increase the bass response, adjust
the frequency and gain of the bass boost according
Some headunits with strong signal output may to your preference. Make sure the “CLIP’’ LED does
reach max power even when the gain is next to its not blink with the new setting.
minimum. In that case, limit the volume of the
headunit right before the point where the clip led
starts blinking.
5
TECHNICAL SPECS
Audio specs
SNR (LPF 15kHz / Nominal power) 73dB
THD + N (Nominal impedance/100Hz/LPF 15kHz/Nominal power) 0.1%
THD + N (Nominal impedance/100Hz/LPF 15kHz/50% of power - 50% Rated Power) 0.09%
THD + N (Nominal impedance/100Hz/LPF 15kHz/10% of power - 10% Rated Power) 0.08%
Frequency reponse (-1dB) 10Hz - 15kHz
Frequency response (-3dB) 5Hz - 20kHz
Damping factor (Nominal impedance @100Hz) >1000
Graphics
Y: 3.0dB/div Vac vs Frequency Marker1 Y: 0,1%/div THD+N Ra o vs Frequency Marker1 X: 45.0 mV/div THD+N Ra o vs Amplitude Marker1
X:---- Hz Y:---% X:---- Hz Y:---% Y: 50.0 m%/div X:---- Hz Y:---%
30.0 Ch 5% Ch 0,5% Ch
1- 1- 1-
24.0 4%
18.0 3% 0,3%
12.0 2% 0,2%
6.0 1% 0,1% X
8000w
0.0 0,0% 0%
20.0 100.0 1.0k 10.0k 20.0k 20.0 100.0 1.0k 10.0k 20.0k 0 Output Power
Dimensions
379mm (14.9'')
6
LIMITED WARRANTY
SounDigital warrants the original purchaser that this product shall be free of defects in materials an workmanship for a
period of twelve (12) months from the original date of purchase. Some countries have extended warranty in case the
product is installed by an authorized dealer. This warranty is not transferrable and applies only to the original customer
from an authorized SounDigital dealer.