Professional Documents
Culture Documents
0 KI00318 2013-02
Software requirements:
- iX Developer 2.0
- Serial/IP
Harware requirements:
- Mitsubishi FX
Page 1 (9)
Beijer Electronics Automation AB a company in the Beijer Electronics Group
Parent Company (Reg. office) Subsidiaries
Beijer Electronics Automation AB Norway, Drammen: Beijer Electronics AS, +47 32 24 30 00
P.O. Box 426 Finland, Helsinki: Beijer Electronics Oy, +358 207 46 35 40
SE-201 24 MALMÖ, SWEDEN Denmark, Copenhagen: Beijer Electronics A/S, +45 70 26 46 46
KI_eng.dot, 070221
Telephone +46 40 35 86 00 Estonia, Tallin: Beijer Electronics Eesti Oü, +372 6 518140
Fax +46 40 93 23 01 Latvia, Riga: Beijer Electronics SIA, +371 7 842280
Visitor’s address Stora Varvsgatan 13a, Malmö Lithuania, Vilnius: Beijer Electronics UAB, +370 5 2323101
www.beijer.se 2 (9)
Transparent mode with iX Developer 2.0 KI00318 2013-02
Make sure that you have FX Series Serial selected in controller. Click OK.
www.beijer.se 3 (9)
Transparent mode with iX Developer 2.0 KI00318 2013-02
Parameter Description
Baud Set the communication speed in baud for the selected COM port.
Data bits Set the data bits for the selected COM port.
Stop bits Set the stop bits for the selected COM port.
When running a panel project you can see settings for the serial ports under System.
Example below is a TxA panel.
KI_eng.dot, 070221
www.beijer.se 4 (9)
Transparent mode with iX Developer 2.0 KI00318 2013-02
Parameter Description
Mode The kind of routing mode used when communicating through the HMI.
The number of seconds with no routing communication the HMI will wait before
Timeout
returning from the routing mode and start functioning normally again.
The serial port used for running routing communication. NOTE: If the HMI is
Serial port connected to the controller using a serial port a different port has to be selected in
this setting.
Baud Set the communication speed in baud for the selected COM port.
Data bits Set the data bits for the selected COM port.
Stop bits Set the stop bits for the selected COM port.
Ethernet port The Ethernet port number used in the HMI for running routing communication.
KI_eng.dot, 070221
www.beijer.se 5 (9)
Transparent mode with iX Developer 2.0 KI00318 2013-02
www.beijer.se 6 (9)
Transparent mode with iX Developer 2.0 KI00318 2013-02
Click on Start.
www.beijer.se 7 (9)
Transparent mode with iX Developer 2.0 KI00318 2013-02
Double click on Serial in the top left corner and select the COM port and transfer speed
used in Serial/IP. Click on Setup and verify the serial setup. Click OK.
KI_eng.dot, 070221
www.beijer.se 8 (9)
Transparent mode with iX Developer 2.0 KI00318 2013-02
Double click on PLC module and select via MAC/MTA transparent mode. Click OK.
www.beijer.se 9 (9)