Professional Documents
Culture Documents
YAS-106/ATS-1060
IMPORTANT NOTICE
This manual has been provided for the use of authorized Yamaha Retailers and their service personnel.
It has been assumed that basic service procedures inherent to the industry, and more specifically Yamaha Products, are already known
and understood by the users, and have therefore not been restated.
WARNING: Failure to follow appropriate service and safety procedures when servicing this product may result in personal injury,
destruction of expensive components, and failure of the product to perform as specified. For these reasons, we advise
all Yamaha product owners that any service required should be performed by an authorized Yamaha Retailer or the
appointed service representative.
IMPORTANT: The presentation or sale of this manual to any individual or firm does not constitute authorization, certification or
recognition of any applicable technical capabilities, or establish a principle-agent relationship of any form.
The data provided is believed to be accurate and applicable to the unit(s) indicated on the cover. The research, engineering, and service
departments of Yamaha are continually striving to improve Yamaha products. Modifications are, therefore, inevitable and specifications
are subject to change without notice or obligation to retrofit. Should any discrepancy appear to exist, please contact the distributor's
Service Division.
WARNING: Static discharges can destroy expensive components. Discharge any static electricity your body may have
accumulated by grounding yourself to the ground buss in the unit (heavy gauge black wires connect to this buss).
IMPORTANT: Turn the unit OFF during disassembly and part replacement. Recheck all work before you apply power to the unit.
■ CONTENTS
TO SERVICE PERSONNEL ............................................2 BLOCK DIAGRAM ........................................................ 17
PANEL LAYOUTS ...........................................................4 WIRING DIAGRAM ....................................................... 18
REMOTE CONTROL PANELS .......................................7 PRINTED CIRCUIT BOARDS ....................................... 19
SPECIFICATIONS / 参考仕様 .........................................8 SCHEMATIC DIAGRAMS .............................................23
INTERNAL VIEW .......................................................... 11 REPLACEMENT PARTS LIST ......................................28
SERVICE PRECAUTIONS / サービス時の注意事項 ..... 11 PROTECTION DISPLAY / プロテクションの表示 ........30
DISASSEMBLY PROCEDURES / 分解手順 ................. 12
2
YAS-106/ATS-1060
YAS-106/ATS-1060
• When installing on the PC board by soldering, solder batterityp eller an ekvivalent typ som rekommenderas
using the connection terminals provided on the battery av apparattillverkaren. Kassera använt batteri enligt
cells. Never solder directly to the cells. Perform the fabrikantens instruktion.
soldering as quickly as possible.
• Never reverse the battery polarities when installing. VAROITUS
• Do not short the batteries. Paristo voi räjähtää, jos se on virheellisesti asennettu.
• Do not attempt to recharge these batteries. Vaihda paristo ainoastaan laitevalmistajan suosittelemaan
• Do not disassemble the batteries. tyyppiin. Hävitä käytetty peristo valmistajan ohjeiden
• Never heat batteries or throw them into fire. mukaisesti.
3
YAS-106/ATS-1060
■ PANEL LAYOUTS
YAS-106
U, C, T, K, A, L, V models
J model
ATS-1060
Top view
YAS-106/ATS-1060
Front view
Rear view
Bottom view
Labels
4
YAS-106/ATS-1060
Labels
YAS-106 (U, C models) YAS-106 (L model)
YAS-106/ATS-1060
YAS-106 (T model) YAS-106 (V model)
YAS-106 (A model)
5
YAS-106/ATS-1060
ATS-1060 (U model)
YAS-106/ATS-1060
ATS-1060 (T model)
ATS-1060 (A model)
ATS-1060 (V model)
6
YAS-106/ATS-1060
YAS-106/ATS-1060
7
YAS-106/ATS-1060
■ SPECIFICATIONS / 参考仕様
■ Audio Amplifier Section / オーディオアンプ部 ■ Bluetooth Section / Bluetooth 部
Impedance / インピーダンス
FRONT L/R ......................................................................6 ohms
SUBWOOFER ........... 3 ohms (6 ohms x 2, parallel connection)
TWEETER ........................................................................6 ohms
8
YAS-106/ATS-1060
Accessories / 付属品
Remote control (with battery) .................................................x 1
Lithium battery (CR2025) ....................................................x 1 The Bluetooth® word mark and logos are registered trademarks owned by
Bluetooth SIG, Inc. and any use of such marks by Yamaha Corporation is
Optical digital audio cable (1.5 m) ........................................x 1 under license.
Analog audio cable [ATS-1060] .............................................x 1 Bluetooth® のワードマークおよびロゴは、Bluetooth SIG、Inc. が所有する登録
商標であり、ヤマハ株式会社はこれらのマークをライセンスに基づいて使用し
Spacer ...................................................................................x 2
ています。
Mounting template .................................................................x 1
Power cable (1.5 m) (T, J models) .........................................x 1
(1.8 m) (U, C, K, A, L, V models) ......................x 1
Manufactured under license from Dolby Laboratories.
Dolby, Dolby Audio, Pro Logic, and the double-D symbol are trademarks of
* Specifications are subject to change without notice.
Dolby Laboratories.
※ 参考仕様および外観は、製品の改良のため予告なく変更する ドルビーラボラトリーズからの実施権に基づき製造されています。
YAS-106/ATS-1060
ことがあります。 Dolby、ドルビー、Dolby Audio、Pro Logic 及びダブル D 記号はドルビーラボ
ラトリーズの商標です。
U .......................U.S.A. model A ................Australian model
C .................Canadian model L .................Singapore model
T .................... Chinese model V ..................... Taiwan model
K ..................... Korean model J .................. Japanese model
Manufactured under license from DTS Licensing Limited.
DTS, the Symbol, & DTS and the Symbol together are registered trademarks,
and DTS Digital Surround is a trademark of DTS, Inc.
© DTS, Inc. All Rights Reserved.
本製品は DTS Licensing Limited のライセンスに基づき製造しています。
DTS、そのシンボルマークおよび DTS とそのシンボルマークの組み合せは、DTS
社の登録商標です。DTS Digital Surround は DTS, Inc. の商標です。
© DTS, Inc. All Rights Reserved.
The terms HDMI, the HDMI Logo, and High-Definition Multimedia Interface
are trademarks or registered trademarks of HDMI Licensing LLC in the
United States and other countries.
HDMI、HDMI ロゴ、および High-Definition Multimedia Interface は、HDMI
Licensing, LLC の商標または登録商標です。
Blu-ray
“Blu-ray Disc™”, “Blu-ray™”, and the logos are trademarks of the Blue-ray
Disc Association.
「ブルーレイ™」および「ブルーレイディスク™」はブルーレイディスクアソシエー
ションの商標です。
iPhone 商標は、アイホン株式会社のライセンスに基づき使用されています。
AAC ロゴマークはドルビーラボラトリーズの商標です。
本機の無線方式について
(Bluetooth)
.......................................................................................... 全帯域を回避可能
9
YAS-106/ATS-1060
• DIMENSIONS / 寸法図
(5-1/8")
131
(2-1/8")
(2")
50
53
Front view
YAS-106/ATS-1060
3
(1/8")
890 (35")
32 (1-1/4")
62
Top view
7–9
(1/4"–3/8") min 20
Front view
(3/4")
4
(5-1/8")
(1/8")
131
13–15
(1/2–5/8")
890 (35") 62
(2-1/2")
Rear view
10 457 (18") Mounting hole size
26.5 (1") ネジ掛け穴サイズ
(3/8")
5 mm
(1/4")
(3-1/2")
89
ø 10
10
YAS-106/ATS-1060
■ INTERNAL VIEW
1 2 3 4
Top view
5 6 7 6 5
Front view
YAS-106/ATS-1060
8 9 8
Rear view
10 11 12
11
YAS-106/ATS-1060
CN418
Fig. 1
12
YAS-106/ATS-1060
YAS-106/ATS-1060
disconnect 2 cables. ます。
d. Remove the power supply unit. d. 電源ユニットを外します。
CON2
③
CN402
②
L/N
②
CN407
CN408
CN401
Fig. 2
13
YAS-106/ATS-1060
HDMI P.C.B. ④
Heatsink
ヒートシンク
MAIN P.C.B.
⑥ ⑥
CN101
AMP (KEY) P.C.B.
CN401 ⑦
Fig. 3
14
YAS-106/ATS-1060
YAS-106/ATS-1060
(Fig. 4)
* The driver removal procedure is the same for ※ スピーカーユニットの外し方は左右同じです。
both right and left. a. ⑨ のネジ 2 本を外します。
a. Remove 2 screws (⑨). b. コネクターの半田を取り除きケーブルを外します。
b. Remove the solder of the connector and disconnect c. コネクターの半田を取り除き電解コンデンサを外
the cable. します。
c. Remove the solder of the connector and remove d. スピーカーユニット(ツィーター)を外します。
the electrolytic capacitor.
d. Remove the driver tweeter.
⑧ ⑧
⑧ ⑧
Driver full-range
スピーカーユニット(フルレンジ)
Driver subwoofer
スピーカーユニット(サブウーファー)
Driver tweeter
スピーカーユニット(ツィーター)
Electrolytic capacitor
電解コンデンサー
Fig. 4
15
YAS-106/ATS-1060
J602
J601
⑫
AMP (REMOTE1) P.C.B.
Fig. 5
16
A B C D E F G H I J
YAS-106/ATS-1060
1 ■ BLOCK DIAGRAM
AMP • See page 27 →
SCHEMATIC DIAGRAM
(AMP)
IC109 TWEETER
MAIN • See page 24–26 → IC403
SCHEMATIC DIAGRAM
FULL-RANGE
(FRONT L/R)
AUX IN
2
DRIVERS
OPTICAL IC112 TWEETER
IC402
IC104
IC110 SUB
3 WOOFER
IC114 SW OUT
HDMI IN
IC1 IC103
4
IC102
AC IN
17
A B C D E F G H I J
YAS-106/ATS-1060
1 ■ WIRING DIAGRAM
AMP
(LED)
J602 J604
2
AMP
(KEY) CN601
J606
AMP
J601
(REMOTE2)
J605 J4 J5 J106 J101 JK101
P601,P602 CN104
3 HDMI
AMP CAPACITOR
(AC_INLET) CN407 CN408 2.2uF 10V
CON2 JR4
L/N
CN101 CN401
J605
AMP
6 (REMOTE1)
18
A B C D E F G H I J
YAS-106/ATS-1060
2
HDMI OUT HDMI IN
MAIN
(CN103)
19
A B C D E F G H I J
YAS-106/ATS-1060
ATS-1060
AMP (AMP)
3 (CN402)
Writing port
MAIN (Side B)
J model
20
A B C D E F G H I J
YAS-106/ATS-1060
DRIVERS
SUBWOOFER
FULL-RANGE
(FRONT L/R)
TWEETER
TWEETER
AMP (Side A) AMP (Side B)
2 (AMP) (AMP)
R
L
L
3
MAIN
(CN101)
5 MAIN
(CN105)
21
A B C D E F G H I J
YAS-106/ATS-1060
AC IN
Power supply unit
22
A B C D E F G H I J
YAS-106/ATS-1060
1 ■ SCHEMATIC DIAGRAMS
FOR INFORMATION ONLY (COMPONENT PARTS NOT AVAILABLE)
HDMI
Page 25 I2
to MAIN_CN103
HDMI IN
HDMI OUT
● 印のある部品は、安全性確保部品を示しています。部品の交換が必要な場合、
7 パーツリストに記載されている部品を使用してください。
● 本回路図は標準回路図です。改良のため予告なく変更することがあります。
23
A B C D E F G H I J
YAS-106/ATS-1060
MAIN 1/3
2
Page 27 E7
to AMP (AMP)_CN401
5
Page 27 H2
to AMP (LED)_J604
● 印のある部品は、安全性確保部品を示しています。部品の交換が必要な場合、
7 パーツリストに記載されている部品を使用してください。
● 本回路図は標準回路図です。改良のため予告なく変更することがあります。
24
A B C D E F G H I J
YAS-106/ATS-1060
MAIN 2/3
2 OPTICAL
AUX IN Page 23 I2
to HDMI_JR4
4
Page 27 A3
to AMP (AMP)_CN402
● 印のある部品は、安全性確保部品を示しています。部品の交換が必要な場合、
7 パーツリストに記載されている部品を使用してください。
● 本回路図は標準回路図です。改良のため予告なく変更することがあります。
25
A B C D E F G H I J
YAS-106/ATS-1060
MAIN 3/3
SW OUT
Writing port
5
★ Components having special characteristics are marked and must be replaced ● 印のある部品は、安全性確保部品を示しています。部品の交換が必要な場合、
7 with parts having specifications equal to those originally installed. パーツリストに記載されている部品を使用してください。
★ Schematic diagram is subject to change without notice. ● 本回路図は標準回路図です。改良のため予告なく変更することがあります。
26
A B C D E F G H I J
YAS-106/ATS-1060
AMP (LED)
AMP
2 (AMP)
Page 24 I5
to MAIN_CN104
Indicators
3
Page 25 I4
R TWEETER
to MAIN_CN105
R FULL-RANGE
Remote control
(FRONT L/R) sensor
L
DRIVERS
L TWEETER
L
SUBWOOFER
4 R AMP (REMOTE2)
AMP (KEY)
(Power)
AMP (AC_INLET)
6
AC IN
to Power supply unit
to Power supply unit Page 24 B2 ★ Components having special characteristics are marked and must be replaced
to MAIN_CN101 with parts having specifications equal to those originally installed.
★ Schematic diagram is subject to change without notice.
● 印のある部品は、安全性確保部品を示しています。部品の交換が必要な場合、
7 パーツリストに記載されている部品を使用してください。
● 本回路図は標準回路図です。改良のため予告なく変更することがあります。
27
A B C D E F G H I J
YAS-106/ATS-1060
* 31
27
7
3
11 3
* 4
20 (LED)
49 30
28
27 *
28 27
27
7
6 16
29
* 29 *
20 (REMOTE2)
27 27
28 27 * 50
4 51 27
28 6
*
27 27 27 28 28
27
* 27
18 20 28
(AC_INLET) 27
27
17 15 27 *
20 (AMP)
27
5
24
200 * 21
19
20 (KEY)
* 27
200-1 27
6
26 18
202
203 ATS-1060 204
23
205 206
23
7
26
28
YAS-106/ATS-1060
WARNING
● Components having special characteristics are marked and must be replaced with parts having specifications equal to those
originally installed.
● 印のある部分は、安全確保部品を示しています。部品の交換が必要な場合、パーツリストに記載されている部品を使用してください。
Ref No. Part No. Description Remarks Markets 部 品 名 Ref No. Part No. Description Remarks Markets 部 品 名
* 1 ZW726000 PANEL LENS 354-000196-100X0 パネルレンズ ACCESSORIES 付属品
* 1 ZW725900 PANEL LENS YAS-106 354-000196-000X0 UCTKALV パネルレンズ * 200 ZV289500 REMOTE CONTROL FSR77 with BATTERY 643-YS106*-07BX0 J リモコン
* 1 ZW726100 PANEL LENS ATS-1060 354-000196-200X0 UTAV パネルレンズ * 200 ZV289600 REMOTE CONTROL FSR78 with BATTERY 643-YS106*-05BX0 UCTKALV リモコン
* 2 ZW727400 DRIVER TWEETER 2.5cm 6Ω 200-011097-101X0 スピーカーユニット * 200-1 ZW725700 BATTERY HOLDER for REMOTE CONTROL 300-N02858-000X0 バッテリーホルダー
* 3 ZW726300 FRONT CABINET ASSEMBLY with TOP CABINET,CLOTH 646-YS106*-07BX0 JTKALV フロントキャビネットAss’y * 202 ZW726700 OPTICAL DIGITAL AUDIO CABLE 1.5m 153-01015A-NM0X1 光デジタルケーブル
* 3 ZW726200 FRONT CABINET ASSEMBLY with TOP CABINET,CLOTH 646-YS106*-05BX0 UC フロントキャビネットAss’y * 203 ZW724300 ANALOG AUDIO CABLE RCA 3.5mm/MINI PLUG 1pc ATS-1060 156-A0215A-NM0X1 UTAV RCAアナログ音声ピンケーブル
* 4 ZW725000 SIDE PANEL 300-N02852-000X0 サイドパネル * 204 ZW725100 SPACER 89x10x8 1pc 360-010222-000X0 スペーザー
* 6 ZW727300 DRIVER FULL-RANGE 5cm 6Ω 200-011096-201X0 スピーカーユニット * 205 ZW726800 MOUNTING TEMPLATE 1pc 400-083654-000Y0 取付用テンプレート
* 7 ZW727200 DRIVER SUBWOOFER 7.5cm 6Ω 200-011095-301X0 スピーカーユニット * 204 ZW726900 POWER CABLE 1.5m 1pc 150-021501-008X0 J 電源コード
* 11 ZW724500 INDICATOR LENS 9P 300-N02855-000X0 インジケーターレンズ 204 ZV162400 POWER CABLE 1.8m 1pc 150-021801-001X1 UC 電源コード
* 15 ZW724200 P.C.B. BAY COVER 300-N02851-000X0 PCBベイカバー 204 ZV162100 POWER CABLE 1.5m 1pc 150-021500-000X0 T 電源コード
* 16 ZW727100 POWER SUPPLY UNIT SMPS 212-011313-001X0 JTKALV 電源ユニット 204 ZV162600 POWER CABLE 1.8m 1pc 150-021801-003X1 K 電源コード
* 16 ZW727000 POWER SUPPLY UNIT SMPS 212-011309-001X0 UC 電源ユニット 204 ZV162500 POWER CABLE 1.8m 1pc 150-021801-002X1 A 電源コード
* 17 ZW724000 P.C.B. ASSEMBLY MAIN, with BLUETOOTH 640-YS1062-070X0 J PCB MAIN 204 ZV162300 POWER CABLE 1.8m 1pc 150-021801-000X0 L 電源コード
* 17 ZW723900 P.C.B. ASSEMBLY MAIN, with BLUETOOTH YAS-106 640-YS1062-050X0 UC PCB MAIN 204 ZV162200 POWER CABLE 1.8m 1pc 150-021801-000V1 V 電源コード
* 17 ZW723700 P.C.B. ASSEMBLY MAIN, with BLUETOOTH ATS-1060 640-AS1062-050X0 U PCB MAIN LITHIUM BATTERY CR2025 1pc リチウム電池
* 17 ZW724100 P.C.B. ASSEMBLY MAIN, with BLUETOOTH YAS-106 640-YS1062-160X0 TAL PCB MAIN
* 17 ZW723800 P.C.B. ASSEMBLY MAIN, with BLUETOOTH ATS-1060 640-AS1062-160X0 TA PCB MAIN SERVICE TOOLS サービスツール
* 17 ZW847600 P.C.B. ASSEMBLY MAIN, with BLUETOOTH YAS-106 640-YS1062-250X0 KV PCB MAIN * ZW724400 SPONGE 700x25x2 383-020160-000X0 インシュレーター
* 17 ZW847700 P.C.B. ASSEMBLY MAIN, with BLUETOOTH ATS-1060 640-AS1062-250X0 V PCB MAIN * ZW725800 EVA PACKING 130x8x1 360-030459-000X0 パッキン
● Protection Display
もう一度 (電源)キーを押して電源を入れると、
DD/DTS インジケーターを使って、プロテクション
の要因が表示されます。
● プロテクションの表示
YAS-106/ATS-1060
This unit / 本機 (Top view / 上側 )
YAS-106
U, C, T, K, A, L, V models
J model
ATS-1060
indicator
インジケーター
緑 デジタルアンプの異常 デジタルアンプの温度異常
デジタルアンプの温度異常
4 5*
30