TERRAFLEX is a two-component solvent free TERRAFLEX should not be applied on the surface epoxy resin system. It is designed to incorporate known to suffer from underground moisture. with dry sand on-site application to the required Application consistency. The specially selected resins and Mix component A and B together by low speed additives form an easily finished impervious mixing paddle, ensure homogeneous mix is mortar with high build characteristics whilst achieved. Dry aggregates can be incorporated perform optimum chemical and mechanical into the mix to the desirable consistency. Apply the resistance. It provides an aesthetically pleasing mixed material to the prepared substrate with a seamless floor surface in multiple color blends steel or notch trowel. providing a durable finish equivalent to Cleaning industrial floor surfaces. TERRAFLEX promotes Tools and equipments should be cleaned by thinner better adhesion of the topcoat to the concrete No.17 after use. and helps to prevent pinholes caused by out Consumption gassing. 1.0 kg/m2/mm Advantages Packaging • 100% solids as supplied, solvent-free 30 kg/ set (Part A = 20 kg, Part B = 10 kg) • High impact resistance and compressive Storage strength Store in a cool dry place and protect from direct • Excellent adhesion to prepared sunlight substrates Shelf life 12 months when store in dry condition and • Adjustable consistency properly closed container • High loading of aggregates (10 times Safety Instruction of liquid) Always wear the appropriate safety goggles, Recommended Uses breathing protection, clothing and gloves during • Suit for use in factory and warehouse the handling of any epoxy resins and hardener. Do floors, including loading and processing not smoke. Work with adequate ventilation during area application. Store all materials in a cool, well – • Suit for use for parking lot, showroom, ventilated and dry place, and away from direct laboratory sunlight. Properly dispose all used containers and Typical Properties excess material in accordance to the local Appearance : Part A : Off-White liquid , governing safety rules and regulations. Part B : Brown liquid Full information about health, safety and Percent Solids : 100% environment of this product are provided in the Specific Gravity : 1.05±0.10 Materials Safety Data Sheet Pot Life : 60 minutes Touch Dry : 4 hours Disclaimer The information given here is true, represents our best Hard Dry : 24 hours knowledge and is based not only on laboratory work, but also Fully Cure : 7 days on field experience. However, because of numerous factors Performance Data (at 7 days age) affecting results we offer this information without any Bond strength by slant shear : >9 N/mm2 guarantee and no patent liability is assumed. All products Compressive strength : 98.34 N/mm2 should be used in accordance with the Manufacturer’s instructions. No responsibility can be taken by the Tensile strength : 39.92 N/mm2 manufacturer where conditions of use are beyond our control. Elongation at break : 0.92% It is the responsibility of the user to obtain the most up-to-date Abrasion resistance : 0.01 g. (loss weight) datasheet which supersedes all previous literature. For Hardness (Durometer) : 83 (Shore D) additional information or questions, contact our sales representative. Surface Preparation The concrete surfaces to be coated should be sound, dry, clean, and free from dust, rust, oil, grease, paint or other contaminations. Green concrete should not be coated, new concrete floors should be left for a minimum of 28 days before coating.