Professional Documents
Culture Documents
1. Unchanged
2. Decreased
3. Half
4. Doubled
Answer: Unchanged
1. 2
2. 1
3. 4
4. 3
Answer: 2
Answer: None
1. Partition noise
2. Cosmic noise
3. Jhonson noise
4. Impulse noise
Answer: Dc voltage
1. 2
2. 3
3. 4
4. 1
Answer: 1
8. Analog data having the highest harmonic at 40 kHz generated by a sensor has been
digitized using 6 level PCM; find the generated digital signal rate?
1. 240 kbps
2. 160 kbps
3. 120 kbps
4. 180 kbps
1. Frames
2. Bytes
3. All of the above
4. None of above
11. In a delta modulation scheme, the step height is 80 mV, and the step width is 2 ms.
Find the maximum slope that the staircase can track?
1. 60 V
2. 30 V
3. 50 V
4. 40 V
Answer: 40 V
13. 23 voice channels are sampled uniformly at a rate of 10 kHz and then time division
multiplexed. The sampling process uses flat-top samples with a two µs duration. The
multiplexing operation includes the provision of synchronization by adding an extra
pulse of 2 µs duration. Find the spacing between successive pulses of the multiplexed
signal?
1. Two µs
2. Three µs
3. Four µs
4. One µs
Answer: Two µs
14. A TDM link has 25 signal channels, and each channel is sampled at 7 kHz. If each
sample is represented by 8 bits and contains an additional bit for synchronization, find
the total bit rate for the TDM link?
1. 888 kbps
2. 1209 kbps
3. 695 kbps
4. 1407 kbps
1. 42.57 kW
2. 25.34 kW
3. 37.76 kW
4. 18.55 kW
Answer: 37.76 kW
16. Which of the given device does the data compression?
1. Circuit breakers
2. Microcontroller
3. Switches
4. Source encoder
17. Output data ratio of a 4 bit PCM - TDM system sampling 16 voice channels,
comparing these using µ - law at the rate of 6 kHz and with an frame alignment word,
is_____________
1. 8.03 × 102bit/sec
2. 4.08 × 103bit/sec
3. 6.04 × 104bit/sec
4. 5.97 × 105bit/sec
18. If the turn-on energy loss in a transformer is 55 MJ and turn-off energy loss is 78
mj. If the mean power loss is limited to 220 W, find the maximum switching rate that
can be achieved?
1. 1654.1 cycles/s
2. 1232.7 cycles/s
3. 1862.9 cycles/s
4. 1453.8 cycles/s
19. For an Amplitude modulation signal, the bandwidth is 20 kHz, and the highest
frequency component present is 650 kHz. Find the carrier frequency used for this
amplitude modulation signal?
1. kHz
2. 640 kHz
3. 260 kHz
4. 900 kHz
20. A balanced modulator is used in the generation of which of the following signal?
1. DSB- SC signal
2. ISI signal
3. Frequency Modulation signal
4. SSB -SC signal
22. A satellite receiver with a noise figure of 5.6 dB has a bandwidth of 24 kHz and
comprises a preamplifier with a noise temperature 150 k and a gain of 40 dB. If the
reference temperature is 300 k, find the equivalent noise temperature of the receiver?
1. 220 K
2. 450 K
3. 300 K
4. 150 K
Answer: 150 K
23. In frequency modulation broadcast, the maximum deviation is 80 kHz, and the
maximum modulating frequency is 20 kHz. In reference to Carson's rule, find the
maximum required bandwidth?
1. 200 KHz
2. 80 KHz
3. 150 KHz
4. 300 KHz
24. If noise figure of a receiver is 1.8 at 20 o C, find its equivalent noise temperature?
1. 184.6 K
2. 234.4K
3. 384.8 K
4. 474.9K
Answer: 234.4K
1. 109 kW
2. 172 kW
3. 120 kW
4. 142 kW
Answer: 109 kW
27. If a 120 V carrier peak changes from 170 V to 50 V by a modulating signal, find the
modulation factor?
1. 3.5
2. 1.5
3. 0.5
4. 2.5
Answer: 0.5
28. The maximum deviation allowed in a frequency modulation system is 120 kHz. If
the modulating signal frequency is 20 kHz, find the bandwidth requirement as per
Carson's rule?
1. 320 kHz
2. 280 kHz
3. 120 kHz
4. 240 kHz
1. 22 kV
2. 26 kV
3. 12 kV
4. 18kV
Answer: 12 kV
30. If the two signals modulate the same carrier with different modulation depths of 0.4
and 0.8. Find the resulting modulation signal?
1. 0.16
2. 0.89
3. 0.54
4. 0.66
Answer: 0.89
31. A 1200 W carrier is amplitude modulated and has a sideband power of 400 W. Find
the depth of the modulation?
1. 1.059
2. 0.775
3. 1.245
4. 3.689
Answer: 0.775
32. A given AM broadcast station transmits an average carrier power output of 50kW
and uses a modulation index of 0.804 for sign wave modulation. Find the maximum
amplitude of the output if a 60 ohm resistive load represents the antenna?
1. 7.66 kV
2. 1.05 kV
3. 5.88 kV
4. 3.95 kV
Answer: 3.95 kV
1. pll
2. sampler
3. accumulator
4. quantizer
Answer: accumulator
1. quantization noise
2. slope over load distortion
3. All of above
4. None of above