Professional Documents
Culture Documents
Starting System
Starting System
General.1
The starting system is the system that generates mechanical work to
operate the air compressor. While the air compressor driven by GGT at
.normal operation
The staring system includes expansion turbine. The gas flow
entering the gas turbine starting system must be performed at the
following condition:
Pressure minimum 16 barg = 232 PSIG
maximum 20 barg = 290 PSIG
Temperature minimum 50 oC = 122 oF
maximum 60 oC = 140 oF
Flow Normal 4.0 Kg/sec = 8.8 Lbs/sec.
ZV
NV 171 FI 171 171
F 0 171
ZV
172
PCV
NV 171 171
VENT LIS
F 0 173
171 ET 001
STARTING GAS
IV
F 0 172 BV 171
172
LBS 300 ”4 ”3
1” 300 LBS
”3
X 1.5 12 SCV
P=235 PSIG =16.2BARG
171
M=8.8LB/S =4.0KG/S
ENCLOSURE
1” 150 LBS
LBS 150 ”12
BACK PRESSURE
ZV
Expansion turbine inlet valve
NV 171 FI 171 Expansion
Gas shut-offturbine
171
valve
,The inlet valve with a linked spring-opposed Drain actuator is pilotFoperated
valve 0 171 valve ZV171
,The
Thetwo stagevalve
shut-off expansion
with aturbine is designed using
linked spring-opposed processisgas
actuator during
pilot startvalve
operated up
The Usingvalve
drain operating
with aair. Thespring-opposed
linked actuator is ZV
oriented to open
actuator is theoperated
pilot valve valve
but it canZV172,Using
also run idle operating
continuously air. without any
172gas
The actuator flow, driven
is oriented by the
to open theout put shaft
valve
. plug
ZV171,Using operating
PCV with increasing air pressure
air. The actuator is oriented to close the valve
NV 171 171.plug with increasing air pressure
.plug with increasing air pressure
VENT LIS
F 0 173
171 ET 001
STARTING GAS
IV
F 0 172 BV 171
172
LBS 300 ”4 ”3
1” 300 LBS
”3
X 1.5 12 SCV
P=235 PSIG =16.2BARG
171
M=8.8LB/S =4.0KG/S
ENCLOSURE
1” 150 LBS
Orifice plates
Solenoid valves
Limit switch
,The flow
LBS orifice
150 ”12 F0 171 is to perform slow operating of SCV 171
Thethe
To make sure twoinlet
solenoid valvesturbine
are operating
valve is the three
at pneumatic
While
BACK F0expansion
PRESSURE 173 has the corresponding closed
function beginning
for IV 172of starting
valves (SCV 171,
.sequence IV 172,
(purge DV171)
system)
The gas flow used for the expansion
PMAX=1.5 PSIG =0.1 BARG turbine is set by means of orifice F0 172
INSTRUMENT AIR
P=90-125 PSIG=6.2-8.6 BARG PI
171
PSV
171
Purge sequence
NV 171
AIR SUPPLY
SITE ROUND
ZV
NV 171 FI 171 171
F 0 171
ZV
172
PCV
NV 171 171
VENT LIS
F 0 173
171 ET 001
STARTING GAS
IV
F 0 172 BV 171
172
LBS 300 ”4 ”3
1” 300 LBS
”3
X 1.5 12 SCV
P=235 PSIG =16.2BARG
171
M=8.8LB/S =4.0KG/S
ENCLOSURE
1” 150 LBS
LBS 150 ”12
BACK PRESSURE
PMAX=1.5 PSIG =0.1 BARG
INSTRUMENT AIR
P=90-125 PSIG=6.2-8.6 BARG PI PSV Start sequence
171 171
NV 171
AIR SUPPLY
SITE ROUND
ZV
NV 171 FI 171 171
F 0 171
ZV
172
PCV
NV 171 171
VENT LIS
F 0 173
171 ET 001
STARTING GAS
IV
F 0 172 BV 171
172
LBS 300 ”4 ”3
1” 300 LBS
”3
X 1.5 12 SCV
P=235 PSIG =16.2BARG
171
M=8.8LB/S =4.0KG/S
ENCLOSURE
1” 150 LBS
LBS 150 ”12
BACK PRESSURE
PMAX=1.5 PSIG =0.1 BARG