Installation Instructions
GER 615 Heavy Duty Pivot
1 ‘The Hager 615 Heavy Duty Pivot can be used for overlay type Installations.
‘OVERLAY
The Instructions given are for an overlay Installation using a 615 Plvot set mounted right handed.
The 615 Pivot is reversible (not handed). Left hand installation is opposite.
3
Mortise os shown on top and bottom of door if
minimum vertical clearance is. desired.
sottion aye
Horizontal positioning as,
will vary with mullion STORAGE AREA
width. A 11/4" wide
rmuliion, with ‘mulion
feoves ‘centered hor'zon—
tally, is the minimum
width recommended
Mark vertical lines
‘Amount of overioy of —Gn the face of the
‘the door will vary. with rmulfon in order to
rmuliion width and dk horizontally. position
ign requirements. A rmulfon. leaves.
13/16" overiay on the
hinged side is minimum.
>
3/16" (approx.)
‘chamfer on inside
bottom ond top of
seacn of door to
‘Boor. ‘secommadate door
feat bend:
NOTE: Mortising may be eliminated if approximately 1/2”
Clearance at top & bottom is acceptoble.
To cllow for vertical adjustment ond sufficient
cleorance under the door, the bottom mullion leat
shoulé be mounted ot least 1/4” off the floor. if
corpet or other special floor coverings are used,
‘adsitional clearance should be ollowed equal to
their thickness.
Place door leaves
in mortise, mark VERTICAL LINE —
1/8 Mn
Apply bottom hinge to face of mullion using the
center of the elongated hole. Be sure to line up
with previously drawn vertical line.
LEAF (swung out
ofwen
Position top hinge mullion
lecf on mullion ot a-point
from top of bottom hinge
which is equal to door
height less) 5 7/16"
Apaly serew in the center of
{he elongated hole. Before
tightening, raise top hinge
to uppermost position ond
temporarily tighten
the screw,
Wf not
mortising door
feaves then
dimension is
‘oor height,
31/16"
Open bottom door leat to 180" position.
Locate bottom door mortise on bottom hinge door leaf.
Apply screw through elongated hole into predriled hole.
In the same way, locate top door mortise on top hinge
door leaf by dropping top jom® leof. Apply screw into
Predrilied hole,
Moke final door alignment if necessory by topping Apply remaining screws. Tighten cll remcining screws
leaves that have elongated holes. if substantial to complete the installation. Reference template for
horizontal adjustment Is necessary, additional ‘additional information and dimensions.
mortising of the door may be required
HAGER COMPANIES
Form mumacr 17370025 | Revisions 1 | REvsION FOR COMPUTER PATE 11-10-03