Professional Documents
Culture Documents
1 Identification -2
2 Introduction -2
4 General Description -3
5 Functional Blocks -5
6 External Interfaces -6
7 Physical Description -7
8 Power Supply -8
9 Hardware Installation -9
1 Identification
3FE 66721 AA FGLT-A 16 GPON Line Termination Board with Traffic Manager (TM) -
version A
2 Introduction
This document describes the 16-line Gigabit Passive Optical Network (GPON) Line
Termination (LT) board with Traffic Manager - version A.
The FGLT-A:
• Is a line terminating unit for the Intelligent Services Access Manager (ISAM).
• Can be used in the following subracks:
• 7360 ISAM FX subrack
• Provides 16 GPON ports per board and supports 2.488 Gbps downstream rate and
1.244 Gbps upstream rate.
• With Traffic Manager:
The traffic manager provides flexible scheduling and rate limiting on a per class of
service, per service and per subscriber basis for downstream PON traffic.
• Meets ETSI and ANSI specifications.
• Is intended for Central Office (CO) deployment in ISAM FX equipment.
• Can be used in the following operation conditions:
• -5°C to +45°C ambient temperature range, in a single subrack 7360 ISAM FX rack or in
the bottom subrack of a multiple subrack 7360 ISAM FX rack.
Note: Under specific conditions the FGLT-A can be used at temperatures well above
45°C. For more information, see the 7360 ISAM FX Product Information manual, Table
5-3 ISAM FX 7360 LT Temperature Range Support.
• Is hardware ready for Time of Day (ToD)
• Can be hot inserted or extracted.
• Is compliant to the regulations of Reduction of Hazardous Substances (RoHS) and
Waste Electrical and Electronic Equipment (WEEE).
• Is compliant to safety standards IEC / EN 60950-1 and AS/NZS 60950-1, provided
that it is installed, maintained and used according the relevant installation instructions.
4 General Description
The FGLT-A is a GPON line termination board. This board can be installed in a 7360
ISAM FX subrack.
The FGLT-A meets ETSI and ANSI requirements and is intended for CO in ISAM FX
equipment.
The FGLT-A provides termination of 16 GPON ports (2.488 Gbps downstream and
1.244 Gbps upstream).
SFP (Small Form Factor Pluggable) GPON optical modules can be plugged in on the
FGLT-A board. For an overview of the supported pluggable optical modules, see the
Product Information manual of your system.
The FGLT-A generates GPON downstream signals synchronized to a timing reference
from one of the two NT slots. All other clocks and synchronization signals are derived
from on-board oscillators.
The following figures show the position of the FGLT-A in:
• a 7360 ISAM FX-16 subrack; see Figure 1.
• a 7360 ISAM FX-8 subrack; see Figure 2.
• a 7360 ISAM FX-4 subrack; see Figure 3.
NTB
LT 9
Fan unit
Connectors
LT 1
NT B
NT I/O
NT A
NGFC-E
NT I/O
NT A
NGFC-F
5 Functional Blocks
DATA PLANE
...
1GE/2.5GE/10GE PHY IWF GIM 16 GPON
Ctrl packets
CONTROL PLANE
6 External Interfaces
7 Physical Description
View
Figure 5 shows a view of the FGLT-A.
Dimensions:
The dimensions of the FGLT-A are:
• Height: 405 mm
• Width: 225 mm (top) / 205 mm (bottom)
• Board to board pitch: 25 mm
Status LEDS
Figure 6 shows the LEDS on the front of the FGLT-A.
PWR
ALM
Table 2: LEDs
PON LED(1) This LED indicates the OFF The PON is not active. It is safe to
state of the PON. remove the fiber and SFP.
Notes
(1)
These LEDs are located on the left of the corresponding PON interface
8 Power Supply
The FGLT-A is compatible with -48 Vdc nominal and -60 Vdc nominal power supply
systems.
Note: Country dependent tolerances exist regarding the nominal battery voltage values.
9 Hardware Installation
For the hardware installation procedures, see the 7360 ISAM FX Hardware Installation
Manual.