Professional Documents
Culture Documents
NALT-B
Issue: 03
June 2016
1.2 Introduction
1.1 Identification
The following table provides identification of the NALT-B:
Table 1 Identification of the NALT-B
1.2 Introduction
This document describes the multiDSL Line Termination (LT) unit version B.
NTIO/17
NTB/18
NTA
01
02
03
04
05
06
07
08
09
10
11
12
13
14
15
16
Fan unit
BAT Connector
BAT filters
Inlet area
Block
Lamps CBs
• OBCM
The On Board Control Module (OBCM) of the NALT-B provides following
functions:
• Control and management plane
• Network management
• Protocol processing
• Chassis management
• Board control signals
• Board ID signals
• Information storage (EEPROM)
• MDM
The MoDem Module (MDM) is the ADSL PHYsical interface (PHY) of the NALT-
B. The modem implements ADSL, ADSL2, ADSL2+, READSL and Annex M
protocols and provides interface to the user through copper line.
• PWRM
The PoWeR Module (PWRM) distributes the power in the NALT-B.
-48V PWRM
1.7.1 View
Figure 3 shows the front view of the NALT-B:
xDSL
PWR
ALM
1.7.2 Dimensions:
The dimensions of the NALT-B are:
• Height: 405 mm
• Width: 225 mm (top) / 205 mm (bottom)
• Board to board pitch: 25 mm
PWR
ALM
(1): Blinking means the LED goes on for a short period (1 s) and then off again.
(2): Blinking period depends on the download speed.
Customer documentation
Customer Documentation Welcome Page
Technical Support
Customer Documentation Technical Support
Documentation feedback
Customer Documentation Feedback
Copyright 2016.
3FE 26682 BAAA TQZZA