Professional Documents
Culture Documents
IDENTIFICATION
SUPPLIER
Company:
Chubb Fire Safety
A.B.N. 4700 006 7541
314 Boundary Road
Dingley
Vic 3172
Australia
Phone: 1300 369 309
HAZARD RATINGS
Flammability:
Toxicity:
Body Contact:
Reactivity:
Chronic:
SYNONYMS
SHIPPING NAME
None
USE
Firefighting foam concentrate.
Continued…
MATERIAL SAFETY DATA SHEET
CHUBB 3% AFFF, Part # 86280
Issue Date: Wed 8-Oct-2005
Page 2 of 12
PHYSICAL DESCRIPTION/PROPERTIES
APPEARANCE
Clear pale yellow liquid with an organic odour; mixes with water.
IDENTIFICATION
INGREDIENTS
NAME CAS RN %
diethylene glycol monobutyl ether 112-34-5 15-30
hydrocarbon surfactants, unspecified 1.5
magnesium sulfate monohydrate 14168-73-1 <5
fluorosurfactants 1-5
water 7732-18-5 30-60
HEALTH HAZARD
SWALLOWED
The material has NOT been classified by EC Directives or other classification systems as
“harmful by ingestion”. This is because of the lack of corroborating animal or human evidence.
The material may still be damaging to the health of the individual, following ingestion, especially
where pre-existing organ (e.g.liver, kidney) damage is evident. Present definitions of harmful or
toxic substances are generally based on doses producing mortality rather than those producing
morbidity (disease, ill-health). Gastrointestinal tract discomfort may produce nausea and vomiting.
In an occupational setting however, ingestion of insignificant quantities is not thought to be cause
for concern.
EYE
Evidence exists, or practical experience predicts, that the material may cause severe eye irritation
in a substantial number of individuals and/or may produce significant ocular lesions which are
present twenty-four hours or more after instillation into the eye(s) of experimental animals. Eye
contact may cause significant inflammation with pain. Corneal injury may occur; permanent
impairment of vision may result unless treatment is prompt and adequate. Repeated or prolonged
exposure to irritants may produce conjunctivitis. The material may produce severe irritation to the
eye causing pronounced inflammation. Repeated or prolonged exposure to irritants may produce
conjunctivitis.
Continued…
MATERIAL SAFETY DATA SHEET
CHUBB 3% AFFF, Part # 86280
Issue Date: Wed 8-Oct-2005
Page 3 of 12
HEALTH HAZARD
SKIN
The material is not thought to be a skin irritant (i.e. is unlikely to produce irritant dermatitis as
described in EC Directives using animal models). Temporary discomfort, however, may result
from prolonged dermal exposures. Good hygiene practice requires that exposure be kept to a
minimum and that suitable gloves be used in an occupational setting.
Entry into the blood-stream, through, for example, cuts, abrasions or lesions, may produce
systemic injury with harmful effects. Examine the skin prior to the use of the material and
ensure that any external damage is suitably protected.
INHALED
The material is not thought to produce either adverse health effects or irritation of the respiratory
tract following inhalation (as classified by EC Directives using animal models). Nevertheless,
adverse systemic effects have been produced following exposure of animals by at least one other
route and good hygiene practice requires that exposure be kept to a minimum and that suitable
control measures be used in an occupational setting.
Studies with some glycol ethers (principally the monoethylene glycols) and their esters indicate
reproductive changes, testicular atrophy, infertility and kidney function changes. The metabolic
acetic acid derivatives of glycol ethers, not the ether itself, have been found to be the proximal
reproductive toxin in animals. The potency of these metabolites decreases significantly as the
chain length of the ether increases. Consequently glycol ethers with longer substituents (e.g.
diethylene glycols, triethylene glycols) have not generally been associated with reproductive
effects. One of the most sensitive indicators of toxic effects observed from many of the glycol
ethers is an increase in the erythrocytic osmotic fragility in rats. This appears to be related to the
development of haemoglobinuria (blood in the urine) at higher exposure levels or as a result of
chronic exposure.
FIRST AID
SWALLOWED
· Immediately give a glass of water.
· First aid is not generally required. If in doubt, contact a Poisons Information Centre
or a doctor.
EYE
Continued…
MATERIAL SAFETY DATA SHEET
CHUBB 3% AFFF, Part # 86280
Issue Date: Wed 8-Oct-2005
Page 4 of 12
· Removal of contact lenses after an eye injury should only be undertaken by skilled personnel.
HEALTH HAZARD
SKIN
If skin contact occurs:
· Immediately remove all contaminated clothing, including footwear.
· Flush skin and hair with running water (and soap if available).
· Seek medical attention in event of irritation.
INHALED
· If fumes or combustion products are inhaled remove from contaminated area.
· Other measures are usually unnecessary.
ADVICE TO DOCTOR
Treat symptomatically.
EXPOSURE STANDARDS
Operations which produce a spray/mist or fume/dust, introduce particulates to the breathing zone.
If the breathing zone concentration of ANY of the components listed below is exceeded, “Worst Case”
considerations deem the individual to be over overexposed.
At the “Composite Exposure Standard for Mixture” (TWA) (mg/m3): 30 mg/m3
Component Breathing Zone ppm Breathing Zone mg/m3 Mixture Conc (%)
Magnesium sulfate monohydrate 16.6667 5 0
INGREDIENT DATA
Continued…
MATERIAL SAFETY DATA SHEET
CHUBB 3% AFFF, Part # 86280
Issue Date: Wed 8-Oct-2005
Page 5 of 12
concentrations, that is, during inhalation of the aerosol (350mg/m3). Since the only potential effects of
inhalation are restricted to local discomfort (in the aerosol concentration range) the substance is classified
in category 1 for the limitation of exposure peaks.
PRECAUTIONS FOR USE
Teratogenicity studies have not revealed prenatal toxic effects at high oral doses and this ether is classified
in pregnancy risk group C.
MAK Category 1 Peak Limitation: For local irritants Allows excursions of twice the MAK value for 5
minutes at a time, 8 times per shift.
MAK Group C: There is no reason to fear risk of damage to the developing embryo when MAK and
BAT values are observed.
MAK values, and categories and groups are those recommended within the Federal Republic of Germany.
These “dusts” have little adverse effect on the lungs and do not produce toxic effects or organic disease.
Although there is no dust which does not evoke some cellular response at sufficiently high concentrations,
the cellular response caused by P.N.O.C.s has the following characteristics:
· the architecture of the air spaces remain intact,
· scar tissue (collagen) is not synthesised to any degree,
· tissue reaction is potentially reversible.
Extensive concentrations of P.N.O.C.s may:
· seriously reduce visibility,
· cause unpleasant deposits in the eyes, ears and nasal passages,
· contribute to skin or mucous membrane injury by chemical or mechanical action, per se, or by the rigorous
skin cleansing procedures necessary for their removal. (ACGIH)
Continued…
MATERIAL SAFETY DATA SHEET
CHUBB 3% AFFF, Part # 86280
Issue Date: Wed 8-Oct-2005
Page 6 of 12
*
Notice of intended change
WATER:
No exposure limits set by NOHSC or ACGIH
Continued…
MATERIAL SAFETY DATA SHEET
CHUBB 3% AFFF, Part # 86280
Issue Date: Wed 8-Oct-2005
Page 7 of 12
ENGINEERING CONTROLS
General exhaust is adequate under normal operating conditions. Local exhaust ventilation may be
required in special circumstances. If risk of overexposure exists, wear approved respirator.
Supplied-air type respirator may be required in special circumstances. Correct fit is essential to
ensure adequate protection. Provide adequate ventilation in warehouses and enclosed storage areas.
Air contaminants generated in the workplace possess varying “escape” velocities which, in turn,
determine the “ capture velocities” of fresh circulating air required to effectively remove the
contaminant.
Simple theory shows that air velocity falls rapidly with distance away from the opening of a simple
extraction pipe. Velocity generally decreases with the square of distance from the extraction point (in
simple cases). Therefore the air speed at the extraction point should be adjusted, accordingly, after
reference to distance from the contaminating source. The air velocity at the extraction fan, for example,
should be a minimum of 1-2 m/s (200-400 f/min) for extraction of solvents generated in a tank 2 meters
distant from the extraction point. Other mechanical considerations, producing performance deficits
within the extraction apparatus, make it essential that theoretical air velocities are multiplied by
Continued…
MATERIAL SAFETY DATA SHEET
CHUBB 3% AFFF, Part # 86280
Issue Date: Wed 8-Oct-2005
Page 8 of 12
PERSONAL PROTECTION
EYE
Safety glasses with side shields.
Chemical goggles.
Contact lenses pose a special hazard; soft lenses may absorb irritants and all lenses concentrate them.
DO NOT wear contact lenses.
HANDS/FEET
Wear chemical protective gloves, eg. PVC.
Wear safety footwear or safety gumboots, eg. Rubber
OTHER
Overalls.
P.V.C. apron.
Barrier cream.
Skin cleansing cream.
Eye wash unit.
RESPIRATOR
Respiratory protection is required when ANY “Worst Case” vapour-phase concentration is exceeded
(see Computer Prediction in “Exposure Standards”).
^ - Full-face
The local concentration of material, quantity and conditions of use determine the type of personal
protective equipment required. For further information consult site specific CHEMWATCH data
(if available), or your Occupational Health and Safety Advisor.
SAFE HANDLING…
SUITABLE CONTAINER
· Metal can or drum
· Packaging as recommended by manufacturer.
· Check all containers are clearly labelled and free from leaks.
Continued…
MATERIAL SAFETY DATA SHEET
CHUBB 3% AFFF, Part # 86280
Issue Date: Wed 8-Oct-2005
Page 9 of 12
STORAGE INCOMPATIBILITY
Glycol ethers may form peroxides under certain conditions. In the presence of strong bases or the
Continued…
MATERIAL SAFETY DATA SHEET
CHUBB 3% AFFF, Part # 86280
Issue Date: Wed 8-Oct-2005
Page 10 of 12
SAFE HANDLING…
salts of strong bases, at elevated temperatures, the potential exists for runaway reactions. Contact with
aluminium should be avoided. Release of hydrogen gas may result.
None known.
STORAGE REQUIREMENTS
TRANSPORTATION
No restrictions.
MINOR SPILLS
Slippery when spilt.
· Remove all ignition sources.
· Clean up all spills immediately.
· Avoid breathing vapours and contact with skin and eyes.
· Control personal contact by using protective equipment.
· Contain and absorb spill with sand, earth, inert material or vermiculite.
· Wipe up.
· Place in a suitable labelled container for waste disposal.
MAJOR SPILLS
Slippery when spilt.
Moderate hazard.
· Clear area of personnel and move upwind.
· Alert Fire Brigade and tell them location and nature of hazard.
· Wear breathing apparatus plus protective gloves.
· Prevent, by any means available, spillage from entering drains or water course.
· No smoking, naked lights or ignition sources.
· Increase ventilation.
· Stop leak if safe to do so.
· Contain spill with sand, earth or vermiculite.
· Collect recoverable product into labelled containers for recycling.
· Absorb remaining product with sand, earth or vermiculite.
· Collect solid residues and seal in labelled drums for disposal.
· Wash area and prevent runoff into drains.
· If contamination of drains or waterways occurs, advise emergency services.
Continued…
MATERIAL SAFETY DATA SHEET
CHUBB 3% AFFF, Part # 86280
Issue Date: Wed 8-Oct-2005
Page 11 of 12
SAFE HANDLING…
DISPOSAL
· Recycle wherever possible or consult manufacturer for recycling options.
· Consult State Land Waste Management Authority for disposal.
· Bury residue in an authorised landfill.
· Recycle containers if possible, or dispose of in an authorised landfill.
Puncture containers to prevent re-use and bury at an authorised landfill.
EXTINGUISHING MEDIA
The product contains a substantial proportion of water, therefore there are no restrictions on the
type of extinguishing media which may be used. Choice of extinguishing media should take into
account surrounding areas.
Though the material is non-combustible, evaporation of water from the mixture, caused by the heat
of nearby fire, may produce floating layers of combustible substances.
In such an event consider:
· foam
· dry chemical powder
· carbon dioxide
FIRE FIGHTING
· Alert Fire Brigade and tell them location and nature of hazard.
· Wear full body protective clothing with breathing apparatus.
· Prevent, by any means available, spillage from entering drains or water course.
· Use water delivered as a fine spray to control fire and cool adjacent area.
· Avoid spraying water onto liquid pools.
· DO NOT approach containers suspected to be hot.
· Cool fire exposed containers with water spray from a protected location.
· If safe to do so, remove containers from path of fire.
FIRE/EXPLOSION HAZARD
· Combustible.
· Slight fire hazard when exposed to heat or flame.
· Heating may cause expansion or decomposition leading to violent rupture of containers.
· On combustion, may emit toxic fumes of carbon monoxide (CO).
· May emit acrid smoke.
· Mists containing combustible materials may be explosive.
Combustion products include:
carbon dioxide (CO2).
other pyrolysis products typical of burning organic material.
May emit poisonous fumes.
May emit corrosive fumes.
FIRE INCOMPATIBILITY
None known
HAZCHEM
Continued…
MATERIAL SAFETY DATA SHEET
CHUBB 3% AFFF, Part # 86280
Issue Date: Wed 8-Oct-2005
Page 12 of 12
None
CONTACT POINT
COMPANY CONTACT
1300 369 309
End of Report
Continued…