Professional Documents
Culture Documents
The 104 pin PCM is located in either the right or left rear corner of the engine bay.
O R
AD
C U
E
in go
o m
D
nto
Pin # Circuit and Status........................................... Sa Voltage
o m
2 Malfunction Indicator Lamp
o . c
Engine Running
h o
y a
Lamp ON......................................................... Low Volts
@
04
Lamp OFF....................................................... Battery Volts
2 0
3
c e
Intake Air Heater Monitor
an
Ignition ON
orm
Heater ON........................................................ Battery Volts
rf
Heater OFF...................................................... Low Volts
p e
hp
5 Park Brake Switch
Ignition ON
m in
14 4X4 Low Range Indicator Lamp
Do
nto
Engine Running
Lamp ON......................................................... 0 Volts
Lamp OFF.......................................................
Sa Battery Volts
o m
. c
15 Data Bus Negative
o o
a h
Serial Data....................................................... N/A
@ y
04
16 Data Bus Positive
20
Serial Data....................................................... N/A
o r m
rf
Transmission Lever in Park................................ 0 Volts
pe
Transmission Lever in Reverse........................... 0 Volts
19 Tachometer Signal
Engine Idling.................................................... Voltage Pulse
25 Case Ground
All Times......................................................... 0 Volts
R
Lamp OFF....................................................... Battery Volts
D O
29 Clutch Switch (Manual)
U A
C
Ignition ON
Clutch Pedal at Rest......................................... Battery Volts
E
go
Clutch Pedal Depressed.................................... 0 Volts
m in
29 Transmission Control Switch (Auto)
Do
nto
Ignition ON
Switch Open.................................................... 0 Volts
Switch Closed..................................................
Sa Battery Volts
o m
o . c
o
30 Exhaust Pressure Sensor
a h
Engine @ Low Idle............................................ 1 Volt
@ y
Engine @ High Idle........................................... 2 Volts
0 4Switch
31
0
Brake Pressure
2OFF.....................................................
c e
Ignition ON
anBrakes ON.......................................................
Brakes Battery Volts
o r m 0 Volts
rf 36
pe
Water in Fuel Probe
o .c
o
Solenoid Operating........................................... 0 Volts
a h
48
y
Injector Driver Module Electronic Feedback Line
@
04
Ignition ON....................................................... 3 Volts
20
Engine @ Low Idle............................................ 1 Volt
c e
Engine @ High Idle........................................... 0.9 to 3 Volts
p
Transmission Lever in Park................................ 0 Volts
51 Ground
All Times......................................................... 0 Volts
Engine Running
Solenoid ON.................................................... 0 Volts
Solenoid OFF.................................................. Battery Volts
R
All Times......................................................... Battery Volts
D O
58 Vehicle Speed Signal
U A
C
Varies with Vehicle Speed................................. Frequency
E
go
59 Auto Trans Output Shaft Speed Sensor
Varies with Vehicle Speed................................. Frequency
m in
Do
nto
61 Cruise Control Switch
Engine Running
ON Selected....................................................
Sa Battery Volts
m
OFF Selected.................................................. 0 Volts
. c o
Set Selected................................................... 2.8 Volts
o o
Resume Selected............................................. 4.7 Volts
a h
Coast Selected................................................ 0.8 Volts
@ y
Hold Selected.................................................. 6.6 Volts
an
Dependant 0.3 to 4.7 Volts
o r m
rf
64 Auto Trans Range Switch (TR3)
pe
Ignition ON
77 Ground
All Times......................................................... 0 Volts
Ignition ON
O R
Relay Actuated................................................ Low Volts
AD
Relay Not Actuated.......................................... Battery Volts
C U
E
go
81 Auto Trans Electronic Pressure Control Solenoid
Ignition ON....................................................... 8 Volts
m in
Engine @ Low Idle............................................ 10 Volts
Do
nto
Engine @ High Idle........................................... Battery Volts
o o
84
a h
Auto Trans Turbine Shaft Speed Sensor
@ y
Vehicle Driving................................................. Voltage Pulse
0 4 Sensor
87
0
Injection Pressure
2@ON......................................................
e
c Low Idle...........................................
Ignition 0.2 to 0.4 Volts
n
a Engine @ High Idle..........................................
Engine 1 Volt
o r m 2 Volts
rf
ppe
h 89 Accelerator Pedal Position Sensor Signal
Ignition ON....................................................... 0.5 to 0.7 Volts
Engine @ Low Idle............................................ 0.5 to 1.6 Volts
Engine @ High Idle........................................... 3.4 to 4.95 Volts
91 Sensor Ground
All Times.......................................................... 0 Volts
R
Ignition ON....................................................... 0 Volts
Engine @ Low Idle............................................ 6 Volts - 5Hz
D O
Engine @ High Idle........................................... 7 Volts - 30Hz
U A
97 PCM Power Supply from Main Relay
E C
Ignition ON....................................................... Battery Volts
in go
o m
98 Intake Air Heater Relay Control
o D
Ignition ON t
nLow Volts
Relay Actuated.................................................
Sa
om
Relay Not Actuated........................................... Battery Volts
o .c
o
100 Fuel Tank Sender Unit
ah
Ignition ON
y
Dependant upon Fuel Tank Level........................ 0 to 4 Volts
m a
r
Relay Actuated................................................. Low Voltss
f o
er
Relay Not Actuated........................................... Battery Volts
p
hp 103 Ground