Professional Documents
Culture Documents
Eedom PG5
Eedom PG5
Sectioning Tools
(i) Viewpoint -> Enable Sectioning -> Sectioning tools tab appears
Planes mode allows you to make up to six sectional cuts in any plane
(iii) Assist you to see inside models without hiding any item. By default section planes are
created through the centre of the visible area of the model.
Sectioning Tools -> Planes Settings -> Current: Plane 1 (with lightbulb on) ;
(iv) Sectioning Tools -> Planes Settings -> Alignment >Top/Bottom/Front/Back/Left/Right > Move