Professional Documents
Culture Documents
C. Consumable Materials
CM 776 ......................................... Lockwire
CM 780 ......................................... Snap wire
CM 683 ......................................... Locking compound
D. Routine Replacement Parts
None
E. Preliminary steps
(1) Open and/or remove:
(a) LH forward bottom structure inspection door under copilot cabin floor,
(d) static port and pitot head protective covers [ Airborne kit].
F. Procedure
(1) Switch static and dynamic pressure circuit shut-off valves (1) - (2) to "N".
(2) Switch static pressure [ Airborne kit] selector valves (3) to "N".
(3) Disconnect the air data unit, AP (5), landing gear microswitch (6) and according to
version, compensated airspeed indicator/generator (14).
(5) Disconnect static and dynamic pressure hoses (8) - (10) at pilot and copilot manifolds (7)
- (11) behing the instrument panel.
(6) Connect nitrogen cylinder hose to the static and dynamic pressure lines (8) - (10) in turn.
(7) Adjust pressure to 1 bar (14.5 psi) then blast the circuit with nitrogen:
(a) check that the nitrogen escapes from static port and pitot head (4) - (13) orifices,
(b) push in drain valves (12) and check that nitrogen escapes,
(10) Open shut-off valves (1) - (2), drop the nitrogen pressure.
G. Final steps
(1) - Disconnect the AP air data unit, the landing gear microswitch blanking covers and,
according to version, compensated airspeed indicator generator (14).
PRE MOD 0726357:
- Coat the unions with Locking compound CM 683 as per MTC and connect all the
static and dynamic pressure lines (8) - (10).
- Fit snap wire to shut-off valves.
- Checks for leaks.
- Install protective covers.
- Install and close the floor and inspection doors.
Figure 301