Professional Documents
Culture Documents
G6-42P
T E L E H A N D L E R
S P E C I F I C A T I O N S
Turbocharged ROPS/FOPS structure operator cab. 48 in. (1.2 m) or 72 in. (1.8 m)
Fuel Diesel
Cycles 4 Wrap-around dashboard with Side Tilt Carriage
No. of Cylinders 4 easy-to-read gauges. 48 in. (1.2 m) or 72 in. (1.8 m)
Displacement 276 cu in (4.5 L) Steering 100° Swing Carriage
Rated Speed 2,500 rpm Hydraulic power steering with manual backup. 72 in. (1.8 m)
Max. Gross BHP 99 hp (74 kW) Rear wheel steering, 90° pivot around either Drywall Carriage
Fuel Tank 46 gal (174 L) front tire. 72 in. (1.8 m)
Engine Filters Outside turning radius is less than Pallet Forks
Two-stage dry air cleaner—centrifugal chassis length. 2 x 4 x 48 in.
pre-cleaner with continuous dust ejector plus (51 mm x 102 mm x 1.2 m)
cleanable and replaceable dry filter element. Instruments
Volt meter, hourmeter, engine oil pressure, Cubing Forks
Visual service indicator. water temperature, fuel gauge. 2 x 2 x 48 in.
Replaceable fuel filter/water All gauges protected by clear acrylic cover. (51 mm x 51 mm x 1.2 m)
separator element. Truss Boom With or Without Winch
Controls
Full-flow replaceable spin-on engine oil filter. Grouped for operator comfort and 10 ft (3.0 m) or 15 ft (4.57 m) booms
Electrical System convenience. Light Material Handling Bucket
Voltage: 12V Boom lift and crowd on single joystick. 0.75 cu yd (0.57 m3) or
Alternator: 63 amp 1.25 cu yd (0.95 m3)
Battery: 810 Cold Cranking amps at 0°F Left-hand tilt and sway lever.
Vertical Mast
Hydrostatic Drive Foot throttle. 6 ft (1.8 m)
6,300 PSI (43,437 kPa) closed loop with Floor mounted traction lock switch. Swing Mast
piston pump and motors. Optional: Single-lever tilt/sway control 6 ft (1.8 m)
8 micron suction filter for charge pump. mounted on right-hand side of operator. Personnel Work Platform
Self-contained, swashplate design, variable Slip On Crane Hook
displacement, over center, piston pump.
Model
G6-42P
T E L E H A N D L E R
32 ft 28 ft 24 ft 20 ft 16 ft 12 ft 8 ft 4 ft 0 ft
48 ft (14.6 m) Dimensions
44 ft (13.4 m) 70 Length (less forks) . . . . 218 in. (5.53 m)
1
(8.84 m)
4,000 lb (1,814 kg)
20 ft (6.1 m)
20
3,000 lb (1,361 kg)
16 ft (4.9 m)
2,000 lb (907 kg)
12 ft (3.7 m)
1,300 lb (590 kg)
10
8 ft (2.4 m)
4 ft (1.2 m)
0
0 ft (0 m)
-4 ft (-1.2 m) -9 IMPORTANT
-8 ft (-2.4 m) Rated lift capacities shown are with machine
equipped with carriage and pallet forks. The
machine must be level on a firm surface with
undamaged, properly inflated tires. Machine
specifications and stability are based on rated
lift capacities at specific boom angles and
boom lengths. (If specifications are critical,
the proposed application should be discussed
with your dealer.)
DO NOT exceed rated lift capacity loads, as
unstable and dangerous machine conditions
will result.
DO NOT tip the machine forward to determine
the allowable load.
Use only JLG approved attachments with
proper material handler model/attachment
load capacity charts displayed in the operator’s
cab. OSHA requires all rough terrain forklift
operators be trained according to OSHA 29
CFR 1910.178 (1).