a es DIN 7168 Pages
3 Table 8. General lerenues on reual uorout
@ in the relationship between
axially symmetrical features,
fand general tolerances on axial run-out
Tolerance on
radial and axial in-out
inmm
") Mainly applies for precision engineering applications.
at theie ‘maximum material size’, but this
within the linear tolerances,
‘The above tolerances on radial run-out may also obtain inthe case of workpi
QD ces not apply to axial run-out tolerances, because axial run-out must always
5 Designation and indication on drawings of general tolerances as specified in DIN 7168
5.1 Designation of general tolerances for dimensions, only
Example:
DIN 7168 —m
at
DIN number
Tolerance class m as per clause 3 ofthis standard.
5.2. Designation of general tolerances based on ISO 8015
Example:
DIN7168—m—S
IN number
Tolerance class m as per clause 3 for size tolerance.
Tolerance class $ as per subclause 4.1 for tolerances of form and position
5.3 Designation of general tolerances based on principle of ‘envelope requirement without indication on
‘drawing’ as per DIN 7167
> Example:
-m
T
folerance class m as per clause 3 for size tolerance
-c
]
|
|
Tolerance ciass G as per subciause 42 for tolerance of position _____}
i
3