characteristics of different greases
oe We anencempl | tseror | 20 0 ‘rept pe ne
fae eng nd ghee
‘Sine
ms se ues sae 2 a nso | senate fogh ped spas
Saeco
Packing method for ball bearings (Fig. 1)
1. Pack geese evenly between the balls. I an outer ting guided
cage i used, such as 2 phenalc resin cage, apply alight
coating of grease on the guided surface,
2. Rotate the bearing by hand to spread gtease evenly on the
suraces ofthe raceway, bal, and cage.
Packing method for cylindrical roller bearings (Fig. 2)
1. at about 80% ofthe grease amount evenly on ale roling
surface. Avoid puting toa much grease onthe cage bor.
Grease onthe cage bare dificult dsperse during the
running in peed which can result in a rapid ise in
temperature o long running in petiod
Coat ols sufaces wath atin fim of grease, incldng the llr
end laces, taller cage contact points, and along the face edges of
each cage pocket.
Using the remaining 20% of grease, apply 2 thin fm of grease
to the raceway surface of the aur cng.
om a2
tae tet en a eg (ae tec aia Rte eg
BEARING REPLACEMENT GUIDE 259