Professional Documents
Culture Documents
Total Pages : 2
BT-5/D-20 45168
MICROPROCESSOR AND INTERFACING
Paper : ES-301A
UNIT–I
1. Draw and explain the block diagram and pin diagram of
8086 microprocessor and explain its PSW. 15
UNIT–II
3. Sketch and explain the interface of 8 K × 8 RAMs and
8 K × 8 EEPROM using a decoder in minimum mode. What
is the maximum access time of RAMs such that it does not
require wait state when 8086 operates of 8 MHz. 15
45168/PDF/KD/350 [P.T.O.
4. Draw a timing diagram for write cycle in Maximum mode
of 8086 by introducing a wait state for 2 ms in the processor
cycle. 15
UNIT–III
5. (a) Discuss various addressing mode of 8086. 7
(b) Explain the following instructions with an example for
each :
(i) XCHG.
(ii) XLAT.
(iii) DAA.
(iv) AAA. 8
UNIT–IV
7. (a) Describe the operation, characteristic and interfacing
of D/A convertor with 8086 Microprocessor. 7
(b) Write short note on the following : 8
(i) Description and interfacing of 8251.
(ii) Interfacing of 8 × 8 Keyboard.
45168/00/KD/350 2
Roll No. ......................... Total Page : 2
BT–5/D–21 45168
MICROPROCESSOR & INTERFACING
Paper–ES–301A
Time Allowed : 3 Hours] [Maximum Marks : 75
Note : Attempt five questions in all, selecting at least one question from
each Unit. All questions carry equal marks.
UNIT–I
1. (a) How 8086 CLK and RESET signals are generated using 8284 ? Explain
in detail? 9
(b) Discuss the working of EU and BIU of 8086 Microprocessor. 6
2. (a) Draw and explain the relevant pin diagram for 8086 in minimum
mode. 9
UNIT–II
3. Interface the 8086 Microprocessor with two 16K × 16 EPROM chips and
two 16K × 16 RAM chips. Draw the necessary block diagram for the
support of your calculation. 15
4. Draw and discuss the read and write cycle timing diagram of 8086 in
minimum mode. 15
UNIT–III
5. (a) Write as assembly language program to find any power of any number.
7
(b) Discuss the following assemble directives : 8
(i) ASSUME.
(ii) SEGMENT.
45168/K/248
6. What do you mean by instruction format? Explain the following instruction
with the help of suitable example : 15
(i) ADC (ii) LEA (iii) PUSH (iv) INC
(iv) JNZ.
UNIT–IV
7. (a) Design 16 bit I/O port using 8255 and interfaces it with 8086 using
I/O addressing. 7
(b) Explain with a neat diagram the interfacing of stepper motor to 8086
using 8255 in detail. 8
8. (a) Explain the structure of 8086 interrupt vector table with neat
diagram. 6
(b) Discuss DMA with the help of lock diagram. 9
45168/K/248 2
https://www.kuonline.in
BT-4/M-20 34095
MICROPROCESSOR AND INTERFACING
CSE-208N
Time : Three Hours] [Maximum Marks : 75
Unit I
Unit II
(2)L-34095 1
https://www.kuonline.in
Unit III
Unit IV
(2)L-34095 2 __
https://www.kuonline.in