This document summarizes the design of a sea water reverse osmosis system with the following key details:
1. The system will have a capacity of 10,000 m3/d and use open sea water from the Red Sea as its raw water source.
2. It will use a one stage system with SW30 HR LE 400 membrane elements, 40% recovery, and a feed temperature of 25°C.
3. For 45% recovery, the system array would need to be increased to 130 pressure vessels containing 770 membrane elements total.
This document summarizes the design of a sea water reverse osmosis system with the following key details:
1. The system will have a capacity of 10,000 m3/d and use open sea water from the Red Sea as its raw water source.
2. It will use a one stage system with SW30 HR LE 400 membrane elements, 40% recovery, and a feed temperature of 25°C.
3. For 45% recovery, the system array would need to be increased to 130 pressure vessels containing 770 membrane elements total.
This document summarizes the design of a sea water reverse osmosis system with the following key details:
1. The system will have a capacity of 10,000 m3/d and use open sea water from the Red Sea as its raw water source.
2. It will use a one stage system with SW30 HR LE 400 membrane elements, 40% recovery, and a feed temperature of 25°C.
3. For 45% recovery, the system array would need to be increased to 130 pressure vessels containing 770 membrane elements total.
2. Plant Capacity :10,000 m3/d 3. Raw Water :Open Sea (Red Sea) 4. Candidate Membrane Element :SW30 HR LE 400 (13m3/d) High active surface area High rejection Low energy 5. One stage system 6. Feed Temperature 25 °C 7. Percent recovery 40%
8. .If a higher recovery is required ……e.g. 45%
Modify the system array for this effect .
Selection of RO System Array
1. Number of Elements Required 770 element
2. Number of Pressure Vessels, if plant foot
print has no restriction, 7 elements – pressure vessels are selected
3. Array 110 pressure vessels in one stage
4. For increasing the system array to ………….45%
The array should be increased to……………..(130)7
The array may be also increased to lower the feed pressure to suit the original pump pressure .