Professional Documents
Culture Documents
Design Calculation For Embedment Plate
Design Calculation For Embedment Plate
CODE
DESIGN PROCEDURE CALCULATION
SECTION
9.2 Equate the internal forces and solve for a : 0.85 f'c a b = Ae fy
9.3.1 a = Ae fy / (0.85 f'c b )
a = Ae 50 / [ 0.85 (4) (7) ]
a = 2.1 Ae
The stud area not used for moment is available Asv = 2 (0.23-0.16) + 2 (0.23)
for shear transfer by shear friction. Asv = 0.61 in.²
9.2 Design shear strength must be greater than the ø Vn = 0.85 (27.4 kips)
9.3 required strength (ø Vn > Vu) ø Vn = 23.29 kips Accepted
42 t² = 26.02
t² = 0.62
t = 0.787130828056042 in.
Thickness of base Plate required t = 20 mm Thickness
B.5.1.1 Calculate design Load assuming all studs may resist Put = As fut
concurrent tensile load Put = 4 (0.23)(60)
Put = 55.20 kips
Bolt use :
Efective
Size Length (mm) Length
(Ld)(mm)
M16 170 159
Assume the outer boundaries of the stress cone Acp = 5 (5) + 4 (5) (7.1) + (7.1)²pi - 4 (0.79)
are connected by tangens. Acp = 349.3 in.²
Therefore,
Pd = 4(0.65)√f'c Acp
(M16 x 170L is acceptable to use) = 57.44 kips Accepted