You are on page 1of 17

K 5.

85 M

English 2
Español 17
Français 33

5.962-103.0 12/06
HIGH PRESSURE WASHER OPERATOR MANUAL
Model Overview 3 Owner/User Responsibility
Important Safety Instructions 4
Assembly Instructions 6 The owner and/or user must have an
Operating Instructions 7 understanding of the manufacturer’s
Using the Accessories 8 operating instructions and warnings be-
Working with Detergents 8 fore using this pressure washer.
Taking a Break ..five minutes or more Warning information should be empha-
10 sized and understood.
Shutting Down & Clean-Up 10 If the operator is not fluent in English,
Winterizing and Long-Term Storage11 the manufacturer’s instructions and
Care and Maintenance Instructions 11 warnings shall be read to and dis-
Cleaning Tips 12 cussed with the operator in the opera-
Optional Cleaning Accessories 13 tor’s native language by the purchaser/
Troubleshooting 15 owner, making sure that the operator
comprehends its contents.
Safety Alert Symbols Owner and/or user must study and
maintain for future reference the manu-
 DANGER facturers’ instructions.
indicates “an imminently hazardous si-
tuation which, if not avoided, will result
in death or serious injury.” Kärcher Customer Support USA
 WARNING Call: 1-800-537-4129 for help or visit
indicates “a potentially hazardous situa- our website:
tion which, if not avoided, could result in www.karcher-usa.com/home
death or injury.” Please take a moment to register your
 CAUTION pressure washer online at
indicates “a potentially hazardous situa- www.karcher-usa.com/warranty
tion which, if not avoided, may result in
minor or moderate injury or in property Kärcher Customer Service CDN
damage incidents.”
Call: 1-800-537-4129 for help or visit our
Specifications website: www.karcher-canada.com

Operating pressure 1850 PSI Kärcher Customer Support Mexico


Water volume 1.5 GPM Call: 01-800-024-13-13 for help or visit
Amp draw 13 AMPS our website: www.karcher.com.mx
Voltage 120 V
Part No. 1.396-703.0
Serial no.

For household use only!

2 English
MODEL OVERVIEW
1 Water inlet with garden hose 8 Hand crank for hose reel
connector 9 Detergent tank
2 ON/OFF switch with Detergent metering regulator
3 High pressure hose reel 10 Trigger gun
4 Spray Wand Storage 11 Trigger gun safety lock
5 Handle 12 High pressure hose
6 Support de rangement pour cordon 13 Dirtblaster® (Rotating spray wand)
7 Power cord with Ground Fault Cir- 14 Vario Power Spray wand
cuit Interrupter (GFCI)

English 3
IMPORTANT SAFETY INSTRUCTIONS
WARNING – When using this product CAUTION – Gun Kicks Back – Hold
basic precautions should always be fol- with both hands.
lowed, including the following: „ The Trigger Gun Safety Lock pre-
„ Read all the instructions before us- vents the trigger from accidentally
ing the product. being engaged. This safety feature
„ To reduce the risk of injury, close su- DOES NOT lock trigger in the ON
pervision is necessary when a prod- position.
uct is used near children. WARNING – Risk of Electrocution –
„ Know how to stop the product and „ Inspect cord before using – Do not
bleed pressures quickly. Be thor- use if cord is damaged.
oughly familiar with the controls. „ Keep all connections dry and off the
„ Stay alert – watch what you are doing. ground.
„ Do not operate the product when fa- „ Do not touch plug with wet hands.
tigued or under the influence of alco- „ Do not use extension cord with this
hol or drugs. product.
„ Keep operating area clear of all per- „ Connect to individual branch circuit
sons. only.
„ Do not overreach or stand on unsta-  WARNING
ble support. Keep good footing and „ DO NOT SPRAY ELECTRICAL AP-
balance at all times. PARATUS AND WIRING.
„ Follow the maintenance instructions „ DO NOT USE WITH FLAMMABLE
specified in the manual. LIQUIDS AND TOXIC CHEMI-
„ This Product Is Provided With A CALS.
Ground Fault Circuit Interrupter „ HIGH PRESSURE. KEEP CLEAR
Built Into The Power Cord Plug. If OF NOZZLE.
Replacement Of The Plug Or Cord „ INJECTION HAZARD: EQUIP-
Is Needed, Use Only Identical Re- MENT CAN CAUSE SERIOUS IN-
placement Parts. JURY IF THE SPRAY
WARNING – Risk of Injection or Injury PENETRATES THE SKIN. DO NOT
– Do Not Direct Discharge Stream At POINT THE GUN AT ANYONE OR
Persons. ANY PART OF THE BODY. IN
„ High pressure jets can be danger- CASE OF PENETRATION SEEK
ous if misused. The jet must not be MEDICAL AID IMMEDIATELY.
directed at persons, animals, electri- „ THIS SYSTEM IS CAPABLE OF
cal devices, or the unit itself. PRODUCING 1850 PSI TO AVOID
„ Wear safety goggles. RUPTURE AND INJURY, DO NOT
WARNING – Risk Of Explosion – Do OPERATE THIS PUMP WITH
not spray flammable liquids. COMPONENTS RATED LESS
„ Do not use acids and solvents in this THAN 1850 PSI WORKING PRES-
product. These products can cause SURE (INCLUDING BUT NOT LI-
physical injuries to the operator and MITED TO SPRAY GUNS, HOSE
irreversible damage to the machine. AND HOSE CONNECTIONS).
4 English
„ BEFORE SERVICING, CLEANING Should replacement of the plug or cord
OR REMOVING ANY PARTS, become necessary, use only identical
SHUT OFF POWER AND RELIEVE replacement parts that include GFCI
PRESSURE. protection.
„ IF CONNECTION IS MADE TO A Contact Kärcher Customer Support.
POTABLE WATER SYSTEM, THE
WATER SUPPLY
SYSTEM SHALL BE PROTECTED
(Cold Water Only)
AGAINST BACKFLOW.
 CAUTION
SAVE THESE INSTRUCTIONS When connecting the water inlet to the
water supply mains, local regulations of
GROUNDING INSTRUCTIONS your water company must be observed.
In some areas the unit must not be con-
This product must be grounded. If it
nected directly to the public drinking
should malfunction or breakdown,
water supply. This is to ensure that
grounding provides a path of least resi-
there is no feedback of chemicals into
stance for electric current to reduce the
the water supply. Direct connection via
risk of electric shock. This product is
a receiver tank or backflow preventer,
equipped with a cord having an equip-
for example, is permitted.
ment-grounding conductor and a
Dirt in the feed water will damage the
grounding plug. The plug must be plug-
unit. To avoid this risk, we recommend
ged into an appropriate outlet that is
fitting a water filter.
properly installed and grounded in ac-
„ Garden hose must be at least 5/8
cordance with all local codes and ordi-
inch in diameter.
nances.
„ Flow rate of water supply must not
 DANGER
fall below 2 GPM (gallons per
Improper connection of the equipment-
minute).
grounding conductor can result in a risk
„ Flow rate can be determined by run-
of electrocution. Check with a qualified
ning the water for one minute into an
electrician or service personnel if you
empty 5-gallon container.
are in doubt as to whether the outlet is
properly grounded. Do not modify the „ The water supply temperature must
plug provided with the product - if it will not exceed 104°F/40°C.
not fit the outlet, have a proper outlet in- „ Never use the pressure washer to
stalled by a qualified electrician. Do not draw in water contaminated with sol-
use any type of adapter with this pro- vents, e.g. paint thinners, gasoline,
duct. oil, etc.
„ Always prevent debris from being
GROUND FAULT CIRCUIT drawn into the unit by using a clean
INTERRUPTER PROTECTION water source.
This product is provided with a ground-
fault circuit interrupter (GFCI) built into
the plug of the power-supply cord. This
device provides additional protection
from the risk of electric shock.
English 5
ASSEMBLY INSTRUCTIONS
Î STEP 4:
Required Tools (not included)
A Philips Screwdriver, medium size
for final assembling the unit.
B Screwdriver, small size
for connecting high pressure hose
and trigger gun.

Î STEP 5:

Î STEP 1:

Î STEP 6:

Î STEP 2:

Î STEP 7:
Attach the high pressure hose to the
trigger gun. Pull out the locking slide
from the right side of the trigger gun
handle (A), and insert the small end
Î STEP 3: of the high pressure hose into place
(B). Push the locking slide back into
the trigger gun to lock the hose in
position (C).

6 English
OPERATING INSTRUCTIONS
Î STEP 1: Î STEP 5:
Unwind the high pressure hose Plug the Ground Fault Circuit Inter-
completely from the hose reel. rupter (GFCI) into a working outlet.
– Press “RESET” button.
– Press “TEST” button.
Red indicator on “RESET” button
should appear.
– Press “RESET” button again for use.
 WARNING
Î STEP 2: Do not use if above test fails.
Insert the spray wand of your choice
into the trigger gun. Press in against
the spring tension and twist into
locked position.

Note: The actual appearance of the GFCI


may be different from this illustration.

Î STEP 6:
Unlock the trigger gun safety lock.
Î STEP 3: Trigger the gun to eliminate trapped
Connect garden hose to unit’s water air, wait for a steady flow of water to
inlet. emerge from the spray nozzle.

Î STEP 7:
Î STEP 4: Turn on the high pressure washer (I).
Connect garden hose to the cold The motor starts only if the trig-
water source and turn water on ger of the gun is pulled and shuts
completely. off when the trigger is released.

English 7
USING THE ACCESSORIES
 WARNING Dirtblaster®
To avoid serious injury never point
spray nozzle at yourself, other per- „ This nozzle features a 0º pencil jet
sons or animals. which rotates 360º for maximum dirt
cutting action, effectively increasing
Vario Power Spray Wand cleaning performance up to 50%.
„ The Vario Power Spray Wand al- This nozzle combines the cleaning
lows you to adjust the cleaning pres- performance of a 0º pencil jet with
sure. the surface coverage of a wide ang-
To clean at maximum pressure, the le nozzle.
wand must be positioned to the high Not recommended for soft materi-
pressure setting (Max). als, siding, painted surfaces,
For reduced pressure turn the wand decks or autos.
collar in the „Min“ direction. „ Always test an inconspicuous area
To apply detergent, the wand before cleaning with the Dirtblaster.
must be positioned to the low
pressure setting (Mix).

WORKING WITH DETERGENTS


Detergents can only be applied at Î STEP 2:
low pressure setting (Mix). Fill the Detergent Tank with the sel-
Î STEP 1: ected Ready To Use detergent.
Install the Vario Power Spray Wand.
Set the spray wand to the low pres-
sure setting (Mix).

8 English
Î STEP 3: longer life. For Kärcher Detergents,
Adjust detergent metering regulator. check your retailer or visit our website:
- Medium quantity: Central position www.karcher-usa.com/home
- Large quantity: "+" position The following Kärcher detergents
- Small quantity: "-" position are available:
One Gallon ready to use
„ All Purpose & Vehicle Cleaner
„ Deck & Patio Cleaner
„ Heavy Duty Degreaser
„ Exterior House Cleaner
 CAUTION
Never use:
Î STEP 4:
– Bleach, Chlorine products and other
Turn on the pressure washer (I). Pull
corrosive chemicals
trigger to operate unit: Liquid deter-
gent is drawn into the unit and mixed – Liquids containing solvents (i.e.,
with water. Apply detergent to work paint thinners, gasoline, oils)
area. Do not allow detergent to dry – Tri-sodium phosphate products
on surface. – Ammonia products
Î STEP 5: – Acid-based products
Cleaning up: Always draw fresh These chemicals will harm the unit and
water through the detergent tank or will damage the surface being cleaned.
siphon tube when done to flush any Use of these items will void the war-
remaining detergents from the injec- ranty.
tion system.

For best results see Cleaning Tips


for specific information on how to
clean different surfaces.
CAUTION
This unit has been designed for use
with cleaning detergents recommended
by the manufacturer. The use of other
cleaning detergents may affect the op-
eration of the machine and void the
warranty.
Always Use Kärcher Detergent for
Best Results
Kärcher biodegradable detergents are
specially formulated to protect the envi-
ronment and your pressure washer.
The special formula won’t clog the suc-
tion tube filter and will protect the inter-
nal parts of the pressure washer for a

English 9
TAKING A BREAK ..five minutes or more
Î STEP 1:
Release trigger and engage gun
safety lock.
Î STEP 2:
Turn pressure washer to OFF (O)
position.

SHUTTING DOWN & CLEAN-UP


Î STEP 1: Î STEP 5:
Turn the switch to OFF (0) position Wind up the high-pressure hose on
and unplug cord from outlet. the hose reel. Push in the handle of
the crank to block the hose reel.

Î STEP 2:
Turn off the water source. Î STEP 6:
Î STEP 3: Release trigger and engage gun
Press trigger to release water pres- safety lock.
sure.

2 3

Î STEP 7:
Î STEP 4: Store the accessories on the unit.
Disconnect the garden hose from
the water inlet on the unit.

10 English
WINTERIZING AND LONG-TERM STORAGE
Î 1: Disconnect all water connections.  CAUTION
Î 2: Turn on the machine for a few se- Failure to follow the above directions
conds, until the water which had will result in damage to the pump as-
remained in the pump exits, turn off sembly and accessories and will void
immediately. the warranty.
Î 3: Do not allow high pressure hose Kärcher also recommends the regular
to become kinked. practice of using a pump protector like
Î 4: Store the machine and accesso- “Kärcher Pump Guard” to prevent cold
ries in a room which does not reach weather damage during storage in the
freezing temperatures. DO NOT winter months.
store near furnace or other sources
of heat as it may dry out the pump
seals.

CARE AND MAINTENANCE INSTRUCTIONS


Cleaning the water inlet filter Maintenance
Î STEP 1: The unit is maintenance-free.
Pull out washer from the water inlet.
Î STEP 2:
Pull out water inlet filter with flat-
nose pliers.

Î STEP 3:
Rinse out water inlet filter in warm
water.
Î STEP 4:
Reinsert water inlet filter and washer
into the water inlet.

English 11
CLEANING TIPS
Deck Cleaning Cement Patios, Brick and Stone
(with or without detergent). Pre-rinse (with or without detergent). Pre-rinse
deck and surrounding area with fresh cleaning surface with fresh water. If us-
water. If using Kärcher Deck Wash, ap- ing Kärcher Pressure Wash or Degreas-
ply to surface at low pressure. For best er, apply to surface at low pressure. For
results, limit your work area to smaller best results, limit your work area to
sections of approximately 25 square smaller sections of approximately 25
feet. Allow Deck Wash to remain on square feet. Allow Pressure Wash or
surface 1-3 minutes. Do not allow de- Degreaser to remain on surface 1-3 min-
tergent to dry on surface. Rinse at high utes. Do not allow detergent to dry on
pressure in a long sweeping motion surface. Rinse at high pressure in a
keeping the spray nozzle approximately sweeping motion keeping the spray noz-
3-6 inches from the cleaning surface. zle approximately 3-6 inches from the
Always clean from top to bottom and cleaning surface. Always clean from top
from left to right. When moving on to a to bottom and from left to right. For re-
new section of the cleaning surface, be moving extremely stubborn stains, use
sure to overlap the previous section to the Dirtblaster Nozzle.
eliminate stop marks and ensure a
Cars, Boats & Motorcycles
more even cleaning result.
(with or without detergent). Pre-rinse
House Siding
vehicle with fresh water. If using Kärcher
(with or without detergent). Pre-rinse Touchless Vehicle Wash, apply to sur-
cleaning surface with fresh water. If face at low pressure. For best results,
using Kärcher Pressure Wash, apply to clean one side of vehicle at a time and
surface at low pressure (for best resul- always apply detergent from bottom to
ts, limit your work area to sections of top, do not allow detergent to dry on sur-
approximately 6 feet and always apply face. If needed, use special wash brush
detergent from bottom to top). Allow attachment (not included) to remove
Pressure Wash to remain on surface 1- stubborn dirt. Rinse at high pressure in a
3 minutes. Do not allow detergent to dry sweeping motion keeping the spray
on surface, if surface appears to be nozzle approximately 6-8 inches from
drying, simply wet down surface with the cleaning surface (distance should
fresh water. If needed, use special increase when rinsing pin-striping or
wash brush attachment (not included) other sensitive surfaces). Always clean
to remove stubborn dirt. Rinse at high from top to bottom and from left to right.
pressure from top to bottom in an even For best results, wipe surface dry with a
sweeping motion keeping the spray chamois or soft dry cloth.
nozzle approximately 6 inches from the
cleaning surface.

12 English
Barbecue Grills, Outdoor Power Brush Attachment (not included) to re-
Equipment & Gardening Tools move stubborn dirt. Rinse at high pres-
sure in a sweeping motion keeping the
(with or without detergent). Pre-rinse spray nozzle approximately 3-6 inches
cleaning surface with fresh water. If from the cleaning surface. For best re-
using Kärcher Pressure Wash or De- sults, clean from top to bottom and from
greaser, apply detergent at low pressu- left to right.
re. Allow Pressure Wash to remain on
surface 1-3 minutes. Do not allow deter- Recommendations
gent to dry on surface. Rinse at high „ Before cleaning any surface an in-
pressure keeping the spray nozzle ap- conspicuous area should be cleaned
proximately 3-6 inches from the cleaning to test spray pattern and distance for
surface. For removing extremely stub- maximum cleaning results.
born dirt, it may be necessary to move „ If painted surfaces are peeling or
the spray nozzle even closer to the sur- chipping, use extreme caution as
face for greater dirt cutting action. pressure washer may remove the
Patio & Lawn Furniture loose paint from the surface.
„ When using on surfaces which might
(with or without detergent). Pre-rinse come in contact with food, flush sur-
furniture and surrounding area with faces with plenty of drinking water.
fresh water. If using Pressure Wash,
„ For additional cleaning tips, visit our
apply to surface at low pressure. Allow
website at www.karcher-usa.com/
Pressure Wash to remain on surface 1-
home
3 minutes. Do not allow detergent to dry
on surface. If needed use special Wash

OPTIONAL CLEANING ACCESSORIES


Optional accessories are available to Water Pumping Kit
further enhance your cleaning capabili-
ties. These accessories are accurate as Attach this accessory to your pressure
of the printing date of this manual. washer to quickly pump large quantities
Please check our website of water out of a standing source, such
www.karcher-usa.com/home for pricing as a barrel or bucket. Fits most Karcher
and up-to-date information. pressure washers up to 2300 PSI.
Part No. 2.637-214.0
Pump Guard
66" Extension Wand (Four piece)
Specially formulated to protect your
pressure washer from freezing, corro- Need to clean second story windows or
sion and premature wear. The Pump other high areas? Increase the reach of
Guard also adds lubrication to valves your pressure washer by up to 66" with
and seals to prevent sticking. Highly this extension kit. Includes 4 aluminum
recommended for all Karcher pressure sections for variable length. 66" fully as-
washers! sembled. Fits most Karcher pressure
Part No. 9.558-998.0 washers up to 2300 PSI. (bayonet)
Part No. 2.640-746.0
English 13
Rotating Wash Brush (bayonet) Wet Sandblasting Kit (bayonet)
For more effortless cleaning of all Why spend hours stripping old paint
smooth surfaces (painted, glass and and rust by hand using harsh chemi-
plastic) try Karcher's Rotating Wash cals? Let Karcher's Wet Sandblasting
Brush. Use it on your automobile, Kit do the work! Attach the kit to your
house siding or windows. The water pressure washer, add abrasive material
pressure from your pressure washer and attack the rust and paint with our
causes the inner brushes to gently spin, eco-friendly alternative. Fits most
making your cleaning job much easier. Karcher pressure washers up to 2300
The angle of brush head is adjustable PSI. (bayonet)
to help you reach difficult areas. Excel- Part No. 2.638-792.0
lent for the application of detergent. A Detergent Foamer Attachment
must-have accessory designed for
Karcher pressure washers up to Ideal for applications which require a
2300 PSI. (bayonet) thick foam. Simply fill the resevoir cup
Part No. 2.640-743.0 with liquid pressure washer detergent
to generate a foam spray. Connects di-
Soft Clean Washing Brush
rectly to the trigger gun. Fits most
Made with soft bristles that will not harm Karcher pressure washers up to 2300
painted surfaces. Easily attaches di- PSI. (bayonet)
rectly to the trigger gun. Ideal for stub- Part No. 6.964-507.0
born dirt on cars, boats, patio furniture T 100 Wide Area Surface Cleaner
and other surfaces. Great for applying
detergent. Fits most Karcher pressure For cleaning surfaces such as patios,
washers up to 2300 PSI. (bayonet) terraces and driveways without splash-
Part No. 2.640-740.0 back, there is no better solution than
Karcher's T 100. It saves time by clean-
25 ft. Pipe Cleaning Kit (bayonet)
ing a one foot wide area gently as it
Need to clean blocked pipes, drains or hovers, providing consistent, streak-
downspouts? Karcher's pipe cleaning kit free cleaning. When you finish cleaning
is the answer! The pipe cleaner propels the patio and driveway, remove the
itself forward while simultaneously flus- wand and use the handle to clean ga-
hing out debris. For example, insert the rage doors and other vertical surfaces.
cleaning nozzle in the base of a downs- Includes two nozzles which spin at high
pout, pull the trigger on the pressure wa- speed for optimum results. Our top sell-
sher gun and watch as the nozzle shoots ing accessory for Karcher pressure
out leaves and other debris while clim- washers up to 2300 PSI. (bayonet)
bing upward. Connects directly to the Part No. 2.640-959.0
trigger gun of most Karcher pressure
washers up to 2300 PSI. (bayonet)
Part No. 2.640-747.0

14 English
TROUBLESHOOTING
 CAUTION
Disconnect the machine from the power
source before making any repair.
Symptom Cause Solution
Motor will not start On/Off switch is in the “OFF”Turn switch to the “ON” (I)
(O) position. position
Tripped GFCI plug. Press “RESET” button on
GFCI plug.
Power cord is not plugged in. Plug in power cord.
Electrical outlet does not Try a different outlet.
supply adequate power.
Unit does not reach Diameter of garden hose is Replace with a 5/8 inch or
high pressure. too small. larger garden hose.
Water supply is restricted. Check garden hose for kinks,
leaks and blockage.
Not enough inlet water Open water source full force.
supply.
Water inlet filter is clogged. Remove filter and rinse out in
warm water.
Spray wand is on low Turn spray wand to high
pressure position. pressure position.
Output pressure Not enough inlet water Turn water on full force.
varies high and low. supply. Check garden hose for kinks,
leaks or blockage.
Pump is sucking air. Check that hoses and fittings
are air tight. Turn off machine
and purge pump by squeez-
ing trigger gun until a steady
flow of water emerges
through the nozzle.
Water inlet filter is clogged. Remove filter and rinse out in
warm water.
Discharge nozzle is Blow out or remove debris
obstructed. with a fine needle.
Calcified gun, hose or spray Run distilled vinegar through
wand. detergent suction tube.

English 15
Symptom Cause Solution
No detergent. Detergent suction tube not Check connection.
properly connected to the
machine.
Detergent is too thick. Dilute detergent, for best re-
sults use Kärcher detergent.
Filter on detergent suction Run warm water through filter
tube is clogged. to remove debris.
Damaged or clogged Remove obstruction or re-
detergent suction tube. place detergent suction tube.
Spray wand is in high Turn spray wand tip to low
pressure position. pressure position.
Discharge nozzle is Blow out or remove debris
obstructed. with fine needle.
Garden hose Loose fittings. Tighten fittings.
connection leaks. Missing/worn rubber washer. Insert new washer.
Spray wand leaks. Spray wand not properly Insert the spray wand into the
attached. trigger gun. Carefully press in
against the spring tension
and twist into the locked
position.
Broken o-ring or plastic Call Customer Support
insert.
Pump is noisy. Pump is sucking air. Check that hoses and fittings
are air tight. Turn off machine
and purge pump by squeez-
ing trigger gun until a steady
flow of water emerges
through the nozzle.
Water leaks from Loose fittings. Check that all fittings are
pump (up to 10 tight.
drops per minute is Water seals are damaged or Call Customer Support
permissible). worn.
Oil Drip. Oil seals are damaged or Call Customer Support
worn.

Kärcher Customer Support USA Kärcher Customer Service CDN


If you encounter any additional difficul- Call: 1-800-537-4129 for help or visit our
ties not listed, please call website: www.karcher-canada.com
1-800-537-4129 for help or visit our
Kärcher Customer Support Mexico
website: www.karcher-usa.com/
home Call: 01-800-024-13-13 for help or visit
our website: www.karcher.com.mx
16 English

You might also like