Professional Documents
Culture Documents
Page 1 of 3
Shutdown SIS
Previous Screen
i02118446
The implement cycle time can be checked in order to verify a complaint about slow implement speed.
This test will also help to determine whether all functions are slow or only one function is slow.
2. Allow only one operator on the machine. Keep all personnel away from the machine or in the
view of the operator.
https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/... 9/16/2023
988H Wheel Loader BXY00001-UP (MACHINE) POWERED BY C18 Engine(SEBP39... Page 2 of 3
2. Tilt back the bucket. Lower the lift linkage to the full LOWER position.
4. Move the lift control lever to the full RAISE position. Hold the lift control lever in this position
until the lift cylinder reaches the end of travel.
5. Record the amount of time that is required to the work tool to travel from the ground to the full
RAISE position.
2. Position the bucket barely above the ground. Set the lower kickout.
5. Move the lift control lever to the full LOWER DETENT position.
6. Record the time from the full RAISE position to the lower kickout near the ground.
2. Position the bucket barely above the ground. Set the lower kickout.
5. Move the lift control lever to the full LOWER position. Do not go into the LOWER DETENT
position.
6. Record the time from the full RAISE position to the lower kickout near the ground.
https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/... 9/16/2023
988H Wheel Loader BXY00001-UP (MACHINE) POWERED BY C18 Engine(SEBP39... Page 3 of 3
5. Move the tilt control lever to the full DUMP position. Hold the tilt control lever in this position,
until the bucket is in the full DUMP position.
6. Record the time from the full TILT BACK position to the full DUMP position.
2. Position the bucket approximately 300 mm (12 inch) above the ground.
4. Move the tilt control lever to the full TILT BACK position. Hold the tilt control lever in this
position until the bucket is against the stop.
5. Record the time from the level position to the full TILT BACK position.
Copyright 1993 - 2023 Caterpillar Inc. Sat Sep 16 06:14:02 PDT 2023
All Rights Reserved.
Private Network For SIS Licensees.
https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/... 9/16/2023