Professional Documents
Culture Documents
INFORMATION TECHNOLOGY
1 of 5
Question 1 (25 Marks)
Figure 1 shows the output of show ip protocols that was executed on RouterE. Analyse this
output and respond to the follow up questions below.
c. Router ID 192.168.10.30
2 of 5
Question 2 (15 Marks)
Give short answers to questions on following Questions@ 1 Mark
2.1 True/False: To reach a remote host, you must know the MAC address of the remote
host.
2.2 At the appropriate command prompt, display a routing table with only OSPF routes.
2.4 When a PC sends a packet to another PC in a remote network, what destination addresses
2.7 DHCP uses which protocol and Port Numbers for Client & Server?
2.9 At the appropriate command prompt, display the routing table on your router.
2.10 True/False: To reach a remote host, you must know the IP address of the remote host.
2.11 At the appropriate command prompt(s), prevent a router from propagating RIP
2.12 True/False:RIPv2 is considered classless. And give the multicast address for RIPv2
2.13 At the appropriate command prompt, display the neighbor table in any OSPF configured
router.
3 of 5
Question 3 (30 Marks)
with RIP version 2, what would be the routing table for RouterD? (10 Marks)
3.4 With an example, describe how you would validate connectivity between PC1 and
PC3. (4 Marks)
4 of 5
Questions 4 (30 Marks)
4.3 Describe the significance of using a DHCP Server in Figure 3 instead of DHCP server
4.4 How would you configure DHCP Server in Figure 3(10 Marks)
4.5 If RouterQ and RouterP are DHCP agents for hosts in Networks192.168.100.0/27,
5 of 5