Professional Documents
Culture Documents
PROCEDURES:
Step 1.
Take a plastic bottle and stationery knife on a 2-3 cm cut both the upper part with a neck.
Next prune at the bottom part of the bottle, approximately 3-4 cm.
Such manipulations are carried out with all the bottles. One of the bottles leave the top with a lid intact, and the
lower part of the prune – and this bottle will be the basis for a broom.
Step 2.
The bottom of the bottle two-thirds slice trim strips width of about 0.5-1 cm.
Step 3.
Take the bottle neck and uncircumcised in inserting into it one by one all the other bottles with lids and cut into
strips.
Step 4.
Take another bottle, the upper part of her left untouched, and prune the lower two-thirds of the total length.
You put the bottle down on everyone else has inserted one into another bottle.
Step 5.
Awl through puncture the crafts have two holes, put them in the wire and firmly fastened on the site.
Step 6.
You put the holder in the neck of the bottle. Ideally, the holder must pass through both the neck of the bottles, but, as
we see, the author crafts did not happen.
Use a hammer and nail to nail holder to bottles.
BROOM IS READY!!!