Professional Documents
Culture Documents
Page 1 of 3
Shutdown SIS
Previous Screen
Product: EXCAVATOR
Model: 320D EXCAVATOR FAL
Configuration: 320D & 320D L Excavators FAL00001-UP (MACHINE) POWERED BY C6.4 Engine
i02742579
Removal Procedure
NOTICE
Contact with high pressure fuel may cause personal injury or death.
Wait 60 seconds after the engine has stopped to allow fuel pressure to
purge before any service or repair is performed on the engine fuel
lines.
NOTICE
NOTICE
https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisw... 14/1/2024
320D & 320D L Excavators FAL00001-UP (MACHINE) POWERED BY C6.4 Engin... Page 2 of 3
Contact with high pressure fuel may cause fluid penetration and burn
hazards. High pressure fuel spray may cause a fire hazard. Failure to
follow these inspection, maintenance and service instructions may cause
personal injury or death.
Note: Cleanliness is a critical factor. Before you begin the removal procedure, the exterior of the
components should be thoroughly cleaned.
Note: Put identification marks on all hoses and on all hose assemblies for installation purposes.
Plug all hose assemblies. This helps to prevent fluid loss, and this helps to keep contaminants from
entering the system.
Illustration 1 g01374509
Installation Procedure
https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisw... 14/1/2024
320D & 320D L Excavators FAL00001-UP (MACHINE) POWERED BY C6.4 Engin... Page 3 of 3
NOTICE
Note: Cleanliness is an important factor. Before assembly, thoroughly clean all parts in cleaning
fluid. Allow the parts to air dry. Do not use wiping cloths or rags to dry parts. Lint may be
deposited on the parts which may cause trouble. Inspect all parts. If any parts are worn or
damaged, use new parts for replacement. Dirt and other contaminants can damage the precision
component. Perform assembly procedures on a clean work surface. Keep components covered and
protected at all times.
Illustration 2 g01374509
2. Connect hose assemblies (4). Install bolts (3). Tighten bolts (3) to a torque of 30 ± 4 N·m
(22 ± 3 lb ft).
Copyright 1993 - 2024 Caterpillar Inc. Sun Jan 14 20:51:43 EST 2024
All Rights Reserved.
Private Network For SIS Licensees.
https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisw... 14/1/2024