Professional Documents
Culture Documents
Classification:
Skin Corrosion/Irritation – Category 1c (H314)
Serious Eye Damage/Irritation – Category 1 (H318)
Specific Target Organ Toxicity (STOT) Single Exposure (SE) – Category 3 (H335)
Specific Target Organ Toxicity (STOT) Single Exposure (SE) – Category 3 (H336)
Reproductive Toxicity – Category 2 (H361)
Specific Target Organ Toxicity (STOT) Repeated Exposure (RE) – Category 1 (H372)
Corrosive to Metal – Category 1 (H290)
Hazard Statements:
H314 – Causes severe skin burns and eye damage
H318 – Causes serious eye damage
H335 – May cause respiratory irritation
H336 – May cause drowsiness or dizziness
H361 – Suspected of damaging fertility or the unborn child
H372 – Causes damage to organs (lungs) through prolonged or repeated exposure
(inhalation)
H290 – May be corrosive to metals
SDS Page 1 of 8
REVISION DATE: January 1, 2020
P270 – Do not eat, drink, or smoke when using this product. Avoid ingestion.
P271 – Use only outdoors or in a well-ventilated area.
P280 – Wear protective gloves/protective clothing/eye protection/face
protection.
Storage
P405 -- Store locked up.
P406 – Store in a corrosion resistant container with a resistant inner liner.
P403 + P233 -- Store in a well-ventilated place. Keep container tightly closed.
INGESTION: Seek medical attention or call poison control center immediately. Do NOT induce
vomiting unless told to do so by a poison control center or doctor. Give nothing by
mouth.
SKIN CONTACT: Immediately flush skin with plenty of soap and water for at least 30 minutes.
Remove contaminated clothing. Seek medical attention.
INHALATION: Remove to fresh air. Seek medical attention.
EYE CONTACT: Immediately flush eyes with plenty of water for at least 30 minutes. Seek medical
attention.
Symptoms/Injuries After Ingestion May be harmful if swallowed. May cause stomach distress, nausea, or vomiting.
SDS Page 2 of 8
REVISION DATE: January 1, 2020
Symptoms/Injuries After Skin Contact Causes severe skin burns and eye damage.
Symptoms/Injuries After Inhalation May cause respiratory irritation. May cause drowsiness or dizziness.
Symptoms/Injuries After Eye Contact Causes serious eye damage.
SDS Page 3 of 8
REVISION DATE: January 1, 2020
Appropriate engineering controls Use only outdoors or in a well-ventilated area.
RESPIRATORY PROTECTION: Follow the OSHA respirator regulations found in 29 CFR 1910.134 or the European
Standard EN 149. Use a NIOSH/MSHA or European Standard EN 149 approved
respirator if exposure limits are exceeded or if irritation or other symptoms are
experienced.
HAND PROTECTION: Wear impervious gloves at all times while working with this product.
EYE PROTECTION: Safety glasses, chemical goggles and/or face shield.
SKIN PROTECTION: Wear suitable protective clothing to prevent skin contact.
WORK/HYGIENE PRACTICES: Avoid contact with eyes. Wash hands after handling. Do not eat, drink, or smoke
during work.
OTHER EQUIPMENT: Make safety shower, eyewash stations, and hand washing equipment available in
the work area.
SDS Page 4 of 8
REVISION DATE: January 1, 2020
Incompatibility (Materials to Avoid): Metals.
Hazardous Decomposition Products: None
Acute Toxicity
Ingestion: May be harmful if swallowed. May cause stomach distress, nausea, or vomiting.
Skin Contact: Causes severe skin burns
Inhalation: May cause respiratory irritation. May cause drowsiness or dizziness.
Eye Contact: Causes serious eye damage.
Chronic Effects/Carcinogenicity
May damage fertility or the unborn child. Causes damage to organs (lungs) through prolonged or repeated inhalation exposure.
No components in product are listed in the National Toxicology Program (NTP) Report on Carcinogens or in the International Agency for
Research on Cancer (IARC) Monographs.
Product Data
There is no toxicological information available for the product mixture.
Component Data
Acute Toxicity
Substance CAS Number LD50 Oral LD50 Dermal LD50 Inhalation
Not applicable due to corrosivity of the substance
Sodium Hydroxide 1310-73-2
Halogenated Sodium
TS No applicable information was found
Benzoate
SDS Page 5 of 8
REVISION DATE: January 1, 2020
Halogenated Sodium
TS No data of sufficient quality are available.
Benzoate
Component Data
Aquatic Ecotoxicity
Substance CAS Number Toxicity to Algae Toxicity to Fish Toxicity to Invertebrates
Leuciscus idus melanotus Ceriodaphnia sp. 48 hr
Sodium Hydroxide 1310-73-2 No information available
48 hr LC50 = 189 mg/L EC50 = 40.4 mg/L
No applicable No applicable information No applicable information
Halogenated Sodium Benzoate TS
information was found was found was found
Bioaccumulation potential
Substance CAS Number Log Pow
Sodium Hydroxide 1310-73-2 No applicable information was found
Halogenated Sodium Benzoate TS No applicable information was found
Mobility in soil
Substance CAS Number Mobility
SDS Page 6 of 8
REVISION DATE: January 1, 2020
Sodium Hydroxide 1310-73-2 No applicable information was found
Halogenated Sodium Benzoate TS No applicable information was found
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA) TITLE III SECTION 313 SUPPLIER NOTIFICATION:
This regulation requires submission of annual reports of toxic chemical(s) that appear in section 313 of the Emergency Planning and
Community Right To Know Act of 1986 and 40 CFR 372. This information must be included in all SDS’s that are copied and distributed
for the material.
The Section 313 toxic chemicals contained in this product are: None
SDS Page 7 of 8
REVISION DATE: January 1, 2020
Massachusetts’s hazardous substance(s): Sodium Hydroxide
Pennsylvania hazardous substance code(s): Sodium Hydroxide
New Jersey Sodium Hydroxide
Illinois Not listed
Michigan Not listed
Rhode Island Sodium Hydroxide
“Disclaimer: This document is generated to distribute health, safety and environmental data. It is not a specification sheet and none of the
displayed data should be construed as a specification. Information on this SDS sheet was obtained from sources which we believe are
reliable, and we believe that the information is complete and accurate. However, the information is provided without any warranty, express
or implied, regarding its correctness. Some of the information presented and conclusions drawn are from sources other than direct test data
of the substance. The conditions or methods of handling, storage, use and disposal of the product are beyond our control and may also be
beyond our knowledge. It is the user’s responsibility to determine the suitability of any material for a specific purpose and to adopt such
safety precautions as may be necessary. If the product is used as a component in another product, this SDS information may not be
applicable. For these reasons, we do not assume any responsibility and expressly disclaim liability for any loss, damage or expense arising out
of or in any way connected with the handling, storage, use or disposal of this product.”
SDS Page 8 of 8