Professional Documents
Culture Documents
Effect of Presure in Ball Bounce Height 2 PDF 3
Effect of Presure in Ball Bounce Height 2 PDF 3
Full description
Save 0% 0% Embed Share Print
Submitted by
ABHISHEK KRISHNAN M
Reg.No. PP16CPHR38
PAYYANUR COLLEGE
Payyanur College
March 2019
DECLARATION
I, ABHISHEK KRISHNAN M , hereby declare that the project work entitled ‘EFFECT OF
PRESSURE IN BALL BOUNCE HEIGHT ‘ submitted to Kannur Universiy in partial fulfillment
of reqirement for the award of Bachelor of Science in Physics is record of original work
done by me under the supervision of Sri. Sreejith E K , Assistant Professor , Department of
Physics , Payyanur College.
I also declare that this project work has not been submitted to me fully or partly for
the award of any other Degree,Diploma , Title or recognition before any other authority.
ABHISHEK KRISHNAN M
BSc.Physcs
Reg.No: PP16CPHR38
Payyanur College
CERTIFICATE
This is to certify that the project work entitled ‘ EFFECT OF PRESSURE OF BALL BOUNCE
HEIGHT ‘ has been carried out by ABHISHEK KRISHNAN M under my supervision in partial
fulfillment of the requirement for the award of Degree of Bachelor Science in Physics of
Kannur University.
ACKNOWLEDGEMENT
I present my whole hearted compliments with high regards and warm thanks to one and
all, who supported me in this project .
With immense pleasure and heartiest gratitude , I express my sincere thanks to my guide
in charge , SREEJITH E K for valuable suggestions and guidance.
I would like to express my gratitude towards all the faculty members , teaching and non-
teaching staffs and classmates fo their support.
CONTENT
1. INTRODUCTION
2. OBJECTIVE
3. MATERIALS REQUIRED
4. PROCEDURE
5. EXPERIMENTAL VARIABLES
6. OBSERVATIONS
7. VELOCITY CALCULATIONS
8. CONCLUSION
1 INTRODUCTION
While watching Basketball games , it was always my interest as to know
why referees would examine the basketball. The basketballs were fully
pumped to my awareness, but I noticed referee checking the air pressure
using a psi barometer. Later I found that the standard indoor basketball
pressure is 8.0 psi . From then, I was curious as to know why basketball
games have this psi regulation. What would the significance if it were to be
slightly high- or vice versa ? Would the speed n which the ball bounces
back from the ground increase if the psi was raised ? These are the
questions which motivated me to answer through this investigation.
Try Scribd FREE for 30 days to access over 125 million titles without ads or interruptions!
Cancel Anytime.
2 OBJECTIVE
The purpose of this investigation is to determine if different measures of
psi have a significanteffect o yhe initial rebound height and velocity of a
basketball.
3 MATERIALS REQUIRED
Meter stick
Recording Device
Ladder (Optional)
BASKETBALL (BALL)
A basketball is a spherical ball used in basketball games. Aside from the court
and the baskets, the basketball is the only piece of equipment necessary to play
the game of basketball. During the game, the ball must be bounced continuously
(dribbling), thrown through the air to other players (passing) or thrown towards
the basket (shooting). Therefore, the ball must be very durable and easy to hold
on to. The ball is also used to perform tricks (sometimes called freestyling), the
most common of which are spinning the ball on the tip of one's index finger,
dribbling in complex patterns, rolling the ball over one's shoulder, or performing
aerobatic maneuvers with the ball while executing a slam dunk, most notably in
the context of a slam dunk contest.
Nearly all basketballs have an inflatable inner rubber bladder, generally wrapped
in layers of fiber and then covered with a surface made either
from leather (traditional), rubber, or a synthetic composite. As in most inflatable
balls, there is a small opening that allows the pressure to be increased or
decreased.
The pound per square inch or, more accurately, pound-force per square
inch (psi) is a unit of pressure or of stress based on avoirdupois units. It is the
pressure resulting from a force of one pound-force applied to an area of
one square inch. In SI units, 1 psi is approximately equal to 6895 N/m2
4 PROCEDURE
Ball selection :
An indoor basketball was utilized for the experiment . The same 75.0
centimeter circumference ball was conduced in all six trials for each psi
levels. Although it is true hat certain materials on the surface of the ball
could result in different impact and various forces, the standard indoor
leather wrapping ball was used. The same area point on the ball was
dropped as well to further reduce any procedural errors.
Drop height :
Every basketball in all psi levels were dropped from the same height of
2.0 meters. This value does not play a role in any of the calculations, but
it is valuable to provide a uniform height for each level.
Rebound height :
This will be calculated from the initial bounce for each psi level. The
average will be taken and it will then be inserted into a graph to
determine significance of the slope .
Rebound Velocity :
5.EXPERIMENTAL VARIABLES
The dependent variable was the basketball rebound height, h, which is measured at the
maximum initial rebound in meters. To measure h, a meter stick was aligned to the wall.
When the ball is dropped from the height of 2.0m and bounce back up, a phone will
record the maximum height it reaches.
The independent variable are the various levels of psi 4.4, 5.0, 5.5, 6.0, 6.5, 7.0, 7.5, 8.0,
8.5, 9.0.
6. OBSERVATIONS
PSI 4.5 5.0 5.5 6.0 6.5 7.0 7.5 8.0 8.5 9.0
Trial 1.258 1.308 1.354 1.397 1.427 1.461 1.483 1.499 1.509 1.511
1
Trial 1.301 1.303 1.361 1.387 1.411 1.473 1.472 1.486 1.509 1.524
2
Trial 1.297 1.306 1.326 1.405 1.410 1.468 1.479 1.506 1.510 1.522
3
Trial 1.279 1.303 1.347 1.401 1.415 1.463 1.481 1.502 1.507 1.515
4
Trial 1.263 1.310 1.351 1.390 1.423 1.470 1.476 1.494 1.511 1.520
5
Trial 1.28 1.315 1.359 1.405 1.410 1.468 1.472 1.496 1.508 1.519
6
Mean 1.281 1.307 1.350 1.397 1.416 1.467 1.477 1.497 1.509 1.518
This graph indicates that as the psi increases, the height in meters rises slightly, but not
as significantly.
As een from the data table and graph , at 4.5 psi, it was at 1.281 meters. But at 9.0 psi,
the height was 1.518 meters. A difference of 0.237 meters was shown.
Height in meters
7. VELOCITY CALCULATIONS
After acquiring the average height for each psi, it was then plugged into a
conservation of energy equation to determine the rate of velocity it was moving
between the ground to the air. This formula will be used:
mgh = (1/2)mv^2
mgh = (1/2)mv^2
gh = (1/2)v^2
v ^2 = 2* 9.8*1.281
PSI
4.5 5.0 5.5 6.0 6.5 7.0 7.5 8.0 8.5 9.0
Rebound
velocity 5.0107 5.0613 5.1439 5.2327 5.2681 5.3622 5.3804 5.4167 5.4384 5.45
46
h in velocity. The r2 value is high (0.95015), suggesting that the dispersion of data is not far from the best fit
line. This reveals how psi does have an effect on rebound velocity, but not significantly because the
difference between the highest (9.0 psi) to (4.5 psi) was only .444 ms-1 apart. Error bars were not needed
herThis graph also indicates a linear growth in velocity. This reveals how psi does have an
effect on rebound velocity, but no significantly because the difference between the
highest (9.0 psi) to (4.5 psi ) was only 0.444 m/s apart.
Try Scribd FREE for 30 days to access over 125 million titles without ads or interruptions!
Cancel Anytime.
8. CONCLUSION
Overall, I was amazed that my data could justify why an 8.0 psi is logical to be the
standard pressure amount. Although the difference at 9.0 psi and 4.5 psi was not as
significant as I would have thought it would be, the slight change in velocity and
rebound height from these two psi levels could indeed impact a lot of players since the
anticipated velocity and height would be much faster or slower. Having all basketballs
regulated at 8.0 psi provides a uniform rate.
BIBILOGRAPHY
“ Do Basketballs that are fully inflated Bounce better than Flatter ones ? “
USCB Science Line, scienceline.ucsb.edu/getkey.php?key=3939.
www.wikipedia.com
Document 12 pages
Document 4 pages
P 6 Fajardolab 1
John De Brito
No ratings yet
Document 15 pages
Document 12 pages
Document 9 pages
Document 11 pages
Document 3 pages
Document 5 pages
P6 Projectile Motion
Kim Valdez
No ratings yet
Document 16 pages
8 Projectile Presentation 1
api-518408081
No ratings yet
Document 4 pages
Document 10 pages
Show more
Scribd for
enterprise
Documents
Language: English