To access option parameters on an i80L machine, one must power off the machine, set a switch to 2, power back on, navigate through menus by pressing keys like F9 and F1, enter a password by pressing 0 eight times, which then allows editing parameters, send the parameters to a computer by outputting them, check that the required parameters were received, power off again, and set the switch back to 0.
To access option parameters on an i80L machine, one must power off the machine, set a switch to 2, power back on, navigate through menus by pressing keys like F9 and F1, enter a password by pressing 0 eight times, which then allows editing parameters, send the parameters to a computer by outputting them, check that the required parameters were received, power off again, and set the switch back to 0.
To access option parameters on an i80L machine, one must power off the machine, set a switch to 2, power back on, navigate through menus by pressing keys like F9 and F1, enter a password by pressing 0 eight times, which then allows editing parameters, send the parameters to a computer by outputting them, check that the required parameters were received, power off again, and set the switch back to 0.
2. Open rear cabinet, set red rotary switch on FC200 board to 2 3. Power on 4. Screen goes direct to NC side, no access to multi side 5. Press “next” key 6. Press function select key F9 7. Press parameter key F1 8. Press option key F5 9. Displays options but does not allow to edit or change 10.Press “0” 8 times 11.Press input key 12.Now allows edit or changing 13.Be careful unless you know which ones you want to change 14.Press “next” key 15.Press parameter output F2 16.Press RS232C key F4 17.Change output baud rate to 2400 (only baud rate I have ever got to work correctly) 18.Press “next” key 19.Arrow down to option parameter 20.Press input to highlight options with an asterisk 21.Press out key F2 22.This will send your options to computer 23.Check you received all the required parameters (D0000-D0049) 24.Power off machine 25.Open rear cabinet, set red rotary switch on FC200 board to “0” 26.Done.