Professional Documents
Culture Documents
IN-BUILT CIP SYSTEM(CLEAN IN PLACE): In high temperature operation of any Hot Water System, the
cleaning of Plate Heat Exchanger is required. THERMAIR© Hot Water System’s effective circulation of non
-toxic fluid cleans the surfaces. This cleaning process maintains efficiency and increase the life of Com-
plete System.
ECO FRIENDLY REFRIGERANT: THERMAIR© Hot Water System are one of the most efficient ways to heat
water all year round. A highly efficient system utilising an environmentally friendly R410A refrigerant
which has zero ozone depletion potential. This refrigerant allows useful heat energy to be absorbed even
in low outdoor temperature.
REDUCED CO2
EMMISIONS
SAVE
MAINTENANCE
FREE
Heat is drawn from the environment surrounding the heat pump which is then turned into heat for
the water heater .
Environmental refrigerant gas absorbs and transfers the heat energy through the refrigeration cir-
culation system.
The fan circulates air through the outer Evaporator Air Coil that acts as a heat collector.
The liquid refrigerant in the air coil absorbs the available heat in the air transforming it to a gas.
The refrigerant gas is then pumped by the Compressor.
When this warmed gas is compressed, it intensifies or concentrates the heat. This intensely hot gas
is then pumped into the Heat Exchanger Condenser where the actual heat exchange takes place.
As the water passes through the Heat Exchanger, the hot gas gives up its heat to the cooler water
thus heating it.
The refrigerant returns to a liquid state and is pumped through the Expansion Valve and then into
the Evaporator Air Coil to start the process over again.
Technical Specification
PE's Model 1-150 1-200 2-300 2-500
Heating Capacity 3.5 KW 3.5 KW 7 KW 7 KW
Input Power Required 0.8 KW 0.8 KW 1.8 KW 1.8 KW
Input Voltage 220 V Single Phase
COP 4.3 4.3
Peak Flow Rate at dT = 30°C 200 lph peak 350 lph peak 500 lph peak 700 lph peak
Peak Flow Rate at dT = 50°C 180 lph peak 300 lph peak 420 lph peak 620 lph peak
Compressor Type Reciprocating / Rotary
Compressor Brand Mitsubishi / Panasonic / Sanyo
Expansion Valve Electronic
Heat Exchanger High Efficient Tube in Tank Heat Exchanger
Ambient Temperature (-5°C to 40°C)
Circulation Pump Not Required
Electrical Warranty 1 Year
Calorifier 150 litres 200 litres 300 litres 500 litres
Calorifier MOC MS with Epoxy / MS with PE’s Coating / SS
Insulation Included
Calorifier Warranty 5 Years / 12 Years / 5 Years
SIZES TO FIT ALL REQUIREMENTS
support@vhil.in
+91-797-268-7844