Professional Documents
Culture Documents
Jaw crusher
The “M” series single toggle Jaw • Unrestricted feed opening mini-
crusher is designed for maximum mises blockages and bridging
of productivity. They are used in a and maximises output.
large range of quarries, to breakup
and recycle material. The resume • Wide range of settings allows the
of the advantages of PEGSONS “M” crusher to operate across a wide
Series Jaw Crushers are: spectrum of applications.
• Robust construction for long In this application very high requirements are placed to the bearing.
life-time. The bearings are manufactured at the FAG location in Wuppertal.
Single toggle jaw crushers are used as coarse crushers Dimensioning
and fine crushers. The jaw has one stationary jaw and
one swing jaw which works by a pitman (swing jaw) The dynamic capacity for bearings used in jaw crushers
mounted on two bearings on an eccentric shaft. This were calculated according to a formula which is lent to
shaft is located in two outer bearings supported in the an empirical derived formula by A. Bonewetsch.
crusher body. The shaft is turned using a pulley drive
and flywheel, which turns the swing jaw in an eccentric The Schaeffler KG Schweinfurt has revised together
motion whilst pivoting on a toggle arrangement at the with BL-PEGSON the bearings of the “M” Series Jaw
bottom of the swing jaw. crusher.
By using a special designed bearing for this application
developed for force – measuring by strain gauges it
was possible to measure forces acting in service.
strain gauge
Heavy Industries
Mining & Processing
Inner system Postfach 1260
97419 Schweinfurt (Germany)
Spherical roller bearing 24068-B-MB Phone +49 9721 91-0
Bore diameter d = 340 mm Fax +49 9721 91-3435
Outside diameter D = 520 mm E-Mail mining_processing@schaeffler.com
Width B = 180 mm Internet www.fag.com