Professional Documents
Culture Documents
com
KP107XL
⚫ Integrated high voltage500V MOSFET KP107XLseries are highly integrated constant currentledPower switch, the chip adopts
⚫ Integrated high voltage self-powered circuit quasi-resonant working mode and does not require auxiliary winding detection
⚫ noneVDDCapacitor design Degaussing. At the same time, there is a high voltage integrated inside500VpowerMOSFET and
⚫ ±5%Constant current accuracy high-voltage self-powered circuitry, simplifying system design and production costs. The chip
⚫ Quasi-resonant mode high efficiency operation integrates high-precision inductor current sampling technology to obtain high
⚫ Ultra-low operating current Accurate constant current output, and the output line voltage and load regulation rate table
⚫ Package typeSOP-7andDIP-7Optional
typical application
⚫ High Powerledillumination
KP107XL
4 HVDD DRAIN 5
3 NC DRAIN 6
2 ROVP
1 GND CS 7
DS_KP107XL_REV1.2_CN
www.kiwiinst.com
©Kiwi Instruments Corp. Confidential 1
KP107XL
Non-isolated, step-down quasi-resonantledPower switch
Pin package
product mark
XXXXXX: Wafer lot XXXXXX: Wafer lot XXXXXX: Wafer lot XXXXXX: Wafer lot XXXXXX: Wafer lot
Y: year code Y: year code Y: year code Y: year code Y: year code
WW: Weekly code,01-52 WW: Weekly code,01-52 WW: Weekly code,01-52 WW: Weekly code,01-52 WW: Weekly code,01-52
ZZ:Serial code,01-99orA0-ZZ ZZ:Serial code,01-99orA0-ZZ ZZ:Serial code,01-99orA0-ZZ ZZ:Serial code,01-99orA0-ZZ ZZ:Serial code,01-99orA0-ZZ
7 65 7 65 7 65 7 65 7 65
7 6 5 7 6 5 7 6 5 7 6 5
DS_KP107XL_REV1.2_CN
www.kiwiinst.com
©Kiwi Instruments Corp. Confidential 2
KP107XL
Non-isolated, step-down quasi-resonantledPower switch
36Voutput 72Voutput
Remark:The maximum output power is limited by the maximum junction temperature of the chip and is combined with the ambient temperaturePCBRegarding the actual system maximum output power, please refer to the test.
Connect the resistor to ground to adjust the output overvoltage protection voltage. It is recommended to use greater than6kresistor
2 ROVP I connected toGND, when the pin is left floating, there is noOVPProtective function.ROVPThe pin also integrates an enable function. When
Ordering information
model describe
DS_KP107XL_REV1.2_CN
www.kiwiinst.com
©Kiwi Instruments Corp. Confidential 3
KP107XL
Non-isolated, step-down quasi-resonantledPower switch
ESDAbility(mannequin) 3 kV
DS_KP107XL_REV1.2_CN
www.kiwiinst.com
©Kiwi Instruments Corp. Confidential 4
KP107XL
Non-isolated, step-down quasi-resonantledPower switch
TLEB Current sampling leading edge blanking time (Remark3) 300 500 700 ns
KP107AL 12 Ω
KP1070L 8.5 Ω
KP1071L 5.3 Ω
Rdson On-resistance
KP1072L 2.5 Ω
KP1073L 1.9 Ω
KP1074L 1.6 Ω
Remark1:Exceeding the "limit parameters" in the list may cause permanent damage to the device. Limiting parameters are stress ratings. The device may not operate properly under recommended
operating conditions and stresses, so operating the device under these conditions is not recommended. Excessive exposure to conditions above recommended maximum operating conditions may affect
device reliability.
Remark2:Maximum power dissipationPDmax=(TJmax-TA)/ƟJA, the maximum power dissipation will decrease when the ambient temperature increases.
Remark3:Parameters depend on the actual design and are functionally tested during series production.
DS_KP107XL_REV1.2_CN
www.kiwiinst.com
©Kiwi Instruments Corp. Confidential 5
KP107XL
Non-isolated, step-down quasi-resonantledPower switch
11.7 7.0
HVDD_OFF(V)
HVDD_On(V)
6.8
11.5
6.6
11.3
6.4
11.1 6.2
- 40 - 20 0 20 40 60 80 100 120 - 40 - 20 0 20 40 60 80 100 120
Temperature(°C) Temperature(°C)
270 604
260 600
250 596
240 592
- 40 - 20 0 20 40 60 80 100 120 - 40 - 20 0 20 40 60 80 100 120
Temperature(°C) Temperature(°C)
DS_KP107XL_REV1.2_CN
www.kiwiinst.com
©Kiwi Instruments Corp. Confidential 6
KP107XL
Non-isolated, step-down quasi-resonantledPower switch
Package size
SOP-7
D
C
L
E1
E
b
A1
A
A2
DS_KP107XL_REV1.2_CN
www.kiwiinst.com
©Kiwi Instruments Corp. Confidential 7
KP107XL
Non-isolated, step-down quasi-resonantledPower switch
Package size
DIP-7
E1
e
C
A2
A
A1
L
B1 B E2
D E
statement
Biyi ensures that the above information is accurate and reliable, and reserves the right to modify the above information without issuing any notice. When integrating BiYi's products into any application,
users should ensure that they do not infringe third-party intellectual property rights; BiYi will not be held legally responsible for any losses caused by failure to use them in accordance with the
DS_KP107XL_REV1.2_CN
www.kiwiinst.com
©Kiwi Instruments Corp. Confidential 8