Professional Documents
Culture Documents
SOL – N16 AU
Use:
Mounting:
2
Place the roof fastener [3] on the sheet metal
4 roof wave [2]. Fasten the fastener by screwing
the self-tapping screws [1] into the roof
3 covering [2] with a prescribed torque of 1.5
Nm.
Attach the mounting profile [5] to the roof
5 fastener [3] by inserting the bolt [4] into the
lower groove of the mounting profile [5]. Then
insert the bolt [4] through the hole [6] in the
fastener. Tightened the nut [7] with
prescribed torque of 10 Nm.
4
6
WARNING!
7 Before mounting, it is necessary to measure
the height, width of trapezoidal shape. The
recommended distance between the load-
bearing elements is less than 1.25 m!
HERMI, d.o.o., Trnoveljska cesta 15, 3000 Celje, Slovenija www.hermi.si info@hermi.si