Professional Documents
Culture Documents
TAS00002XE
TYPE APPROVAL CERTIFICATE Revision No:
2
This is to certify:
That the Modular support substructure system with accessories
Issued to
Hilti AG
Schaan, Liechtenstein
Application :
Modular construction of support systems and substructure for piping systems, components and secondary
steel construction approved by this certificate are accepted for installation on all vessel classed by DNV.
This Certificate is subject to terms and conditions overleaf. Any significant change in design or construction may render this Certificate invalid.
The validity date relates to the Type Approval Certificate and not to the approval of equipment/systems installed.
LEGAL DISCLAIMER: Unless otherwise stated in the applicable contract with the holder of this document, or following from mandatory law, the liability of DNV AS, its
parent companies and their subsidiaries as well as their officers, directors and employees (“DNV”) arising from or in connection with the services rendered for the
Form code: TA 281 Revision: 2022-12 www.dnv.com Page 1 of 5
Job Id: 262.1-027595-3
Certificate No: TAS00002XE
Revision No: 2
purpose of the issuance of this document or reliance thereon, whether in contract or in tort (including negligence), shall be limited to direct losses and under any
circumstance be limited to 300,000 USD.
Product description
HILTI - Channel System
Type designation: MT, MQ channel system items are made of either galvanized steel or hot dip galvanized steel or
stainless steel. The channel system contains the installation channels, brackets, connectors, and accessories.
Complete up to date list of items can be found under: www.hilti.group
Materials:
Key material information for MT & MQ channel systems is shown in the table below. For further detail information for
accessories and other smaller items click on the below link.
https://www.hilti.group/content/hilti/CP/XX/en/products/installation-systems/installation-systems.html
Application/Limitation
Hilti MT and MQ channel systems – are type approved for the modular construction of support systems and
substructures for piping systems, components and secondary steel construction on board ships and other structures
classed by DNV.
It shall be noted that this Type Approval certificate is not valid for designs, components, equipment, systems or products
which are otherwise subject to classification by DNV.
For design and installation, the Hilti “Technical Handbook”, “product data sheets” and “Instruction for Use” specified
online “www.hilti.group” are to be observed.
Marking of product
For traceability to this type approval certificate the products are to be marked with:
- Manufacturers name or trademark
- Type designation
Periodical assessment
For retention of the Type Approval, a DNV Surveyor shall perform periodical assessment after two years (+/- 90 days)
and after 3.5 years (+/- 90 days) to verify that the conditions for the Type Approval are complied with. Refer to DNV-CP-
0338, Sec.4.
The certificate is only valid if required periodical assessments are carried out with satisfactory results. To check the
validity of this certificate, please look it up in https://approvalfinder.dnv.com
END OF CERTIFICATE