To set up the angle sensor mode, follow the diagrams to select the angle sensor model, which is typically 90 degrees but can also be 120 or 360 degrees. Next, select the installation location of the angle sensor on the left, right, or middle position of a tractor. Finally, confirm the centering angle value, which is about 60 degrees for a 90 degree sensor, 240 degrees for a 360 degree sensor, and 90 degrees for a 120 degree sensor.
To set up the angle sensor mode, follow the diagrams to select the angle sensor model, which is typically 90 degrees but can also be 120 or 360 degrees. Next, select the installation location of the angle sensor on the left, right, or middle position of a tractor. Finally, confirm the centering angle value, which is about 60 degrees for a 90 degree sensor, 240 degrees for a 360 degree sensor, and 90 degrees for a 120 degree sensor.
To set up the angle sensor mode, follow the diagrams to select the angle sensor model, which is typically 90 degrees but can also be 120 or 360 degrees. Next, select the installation location of the angle sensor on the left, right, or middle position of a tractor. Finally, confirm the centering angle value, which is about 60 degrees for a 90 degree sensor, 240 degrees for a 360 degree sensor, and 90 degrees for a 120 degree sensor.
Follow the diagram below to switch the system to the angle sensor mode. Figure 2 -5- 2 After the angle sensor selection is completed, we also need to select the installation model of the angle sensor, etc. First select the angle sensor model, the common model is 90 ° . However, 1 20 ° and 360 ° angle sensors are also used. Figure 2 -5- 3 Remark: Before installing the angle sensor, pay attention to check the model of the angle sensor. following figure: 36 is 360° ,if it is 09 , it is 90° ,and 12 is 1 20 °. Figure 2 -5- 4 Then select the installation of the angle sensor. Figure 2 -5- 5 Remark: After selecting the installation location. To ensure that the steering wheel is turned to the left, the centering value decreases. Then turn the steering wheel to the right to increase the centering value. The installation position, if it is installed on the right wheel, choose the right wheel, if it is installed on the left wheel, choose the left wheel, and if it is a hinged tractor, install it in the middle hinge position. Finally, confirm the value change of the centering angle. Figure 2 -5- 6 centering angle of the angle sensor for the 90° model is about 60 ° , the angle sensor for the 360° model is about 240 ° , and the angle sensor for the 120° model is about 90 °. The above content is a reference value, as long as you turn the steering wheel to the left or right, the alignment value will continue to change before the front wheel stops turning.