The document outlines the steps of an experiment to observe how changing electric current through an electromagnet affects the movement of an attached striker and the sound produced by a bell. Materials are set up, iron filings are sprinkled around the electromagnet, and the electromagnet is connected to a power supply. The current is gradually increased while voltage, current, striker movement, and sound are measured and recorded. A graph of decibel level versus current is then plotted.
The document outlines the steps of an experiment to observe how changing electric current through an electromagnet affects the movement of an attached striker and the sound produced by a bell. Materials are set up, iron filings are sprinkled around the electromagnet, and the electromagnet is connected to a power supply. The current is gradually increased while voltage, current, striker movement, and sound are measured and recorded. A graph of decibel level versus current is then plotted.
The document outlines the steps of an experiment to observe how changing electric current through an electromagnet affects the movement of an attached striker and the sound produced by a bell. Materials are set up, iron filings are sprinkled around the electromagnet, and the electromagnet is connected to a power supply. The current is gradually increased while voltage, current, striker movement, and sound are measured and recorded. A graph of decibel level versus current is then plotted.
2. Iron filings will be sprinkled on a flat surface around the electromagnet. 3. The electromagnet will be reconnected to the power supply using wires and connectors. 4. The electric current supplied to the electromagnet will be gradually increased. 5. The multimeter will be used to measure the voltage across the electromagnet and the current flowing through it. 6. These values will be recorded at different current levels. 7. The movement of the striker or clapper in response to changes in the electric current will be observed. 8. Any audible ringing produced by the striking mechanism will be noted. 9. The current supplied to the electromagnet will be gradually adjusted. 10. The striker's movement and the sound produced by the bell will be observed. 11. Observations will be recorded. 12. A Graph of Decibel vs Current will be plotted. • Iron Fillings • Switch • Decibel Meter Method: 1. Materials and apparatus were set up. 2. Iron filings were sprinkled on a flat surface around the electromagnet. 3. The electromagnet was reconnected to the power supply using wires and connectors. 4. The electric current supplied to the electromagnet was gradually increased. 5. The multimeter was used to measure the voltage across the electromagnet and the current flowing through it. 6. These values were recorded at different current levels. 7. The movement of the striker or clapper in response to changes in the electric current was observed. 8. Any audible ringing produced by the striking mechanism was noted. 9. The current supplied to the electromagnet was gradually adjusted. 10. The striker's movement and the sound produced by the bell were observed. 11. Observations were recorded. 12. A graph of Decibel vs Current was plotted.