Professional Documents
Culture Documents
DATA SHEET
211 A2 EN 14387:2004+A1:2008
Cod. 8011109
EN 143:2000+A1:2008 A2
Minimum
Cyclohexane C6H12 (5000
breakthrough > 35
ppm)
time (min)
Breathing inhal 15 l/min < 1,4
Resistance inhal 47,5 l/min < 5,6
(mbar)
Characteristics Certification
211 A2 is a gas filter and protects against gaseous 211 A2 filter meets the requirements of EN 14387:2004 standard
contaminants. 211 A2 filter is equipped with a special bayonet and is CE marked, as provided by 89/686/EEC European
connection allowing to use it, in pair, on BLS half masks EVO R Directive, as a PPE of III category.
and EVO S. Italcert S.r.l. (Notified Body n° 0426) is the responsible of the
certification (Art. 10) and of the product control with surveillance
(Art.11.B). All the products are manufactured in a company that is
ISO 9001:2008 certified.
Application
Certification tests
211 A2 is a filter protecting against organic gases and vapours
211 A2 filter meets the requirements of EN 14387:2004 standard
with a boiling point above 65°C and can be employed with
and has been submitted to the tests provided by class 2.
substances as solvents and microorganisms, etc.
• Breathing Resistance
It is classified, in terms of capacity, as a class 2 filter (medium
The resistance offered from the filter to the air flow must be lower
capacity filter).
as possible and, in any case, must not be greater than the
following values for gas filters (par. 6.11 of EN 14387:2004
standard): with an air flow of 15 l/min shall not exceed 1,4 mbar
Protection and with an air flow of 47,5 l/min shall not exceed 5,6 mbar.
• Gas capacity
Exposure limit for 211 A2 filter: 211 A2 filter has been submitted to tests according to par. 6.12 of
with half mask: for gases and vapours 30 x TLV EN 14387:2004 standard to verify the minimum breakthrough time,
with full face mask: for gases and vapours 400 x TLV when exposed to test gases at determinate concentration. For A2
* NPF as defined in EN 529:2005 standard type, the test gas used is the gas expected in the standard and
reported in the table, with their break-up time
Materials
211 A2 filter is made by:
• filter case: ABS
• filtering component: activated charcoal A type
Height (thread excluded): 29 mm
Diameter: 93 mm
Weight: 82±4 g
These filters can be used on full face masks and half
masks.
June 2012
Pag. 1
Titolo tipologia
DATA SHEET
211 A2 EN 14387:2004+A1:2008
Storage conditions: temperature range -10°C e +50°C, Relative humidity < 80%
Technical Details
June 2012
Pag. 2