The document provides instructions for software setup to enable speed control of a drive using a S7-1500 controller and CU250S-2PN via PROFINET. The software includes TIA Portal v16 with an add-on driver package for SINAMICS firmware V4.7 installed before creating a new project. The drive's Basic Operator Panel 2 is used to reset the drive to factory settings and update the CU250S-2 SINAMICS firmware.
The document provides instructions for software setup to enable speed control of a drive using a S7-1500 controller and CU250S-2PN via PROFINET. The software includes TIA Portal v16 with an add-on driver package for SINAMICS firmware V4.7 installed before creating a new project. The drive's Basic Operator Panel 2 is used to reset the drive to factory settings and update the CU250S-2 SINAMICS firmware.
The document provides instructions for software setup to enable speed control of a drive using a S7-1500 controller and CU250S-2PN via PROFINET. The software includes TIA Portal v16 with an add-on driver package for SINAMICS firmware V4.7 installed before creating a new project. The drive's Basic Operator Panel 2 is used to reset the drive to factory settings and update the CU250S-2 SINAMICS firmware.