Professional Documents
Culture Documents
东方一号(二号)说明书(英文)
东方一号(二号)说明书(英文)
(optional)
Camera module
Display screen
(optional)
Password
button
Power/Setting
button (optional)
Doorbell and
lock button
Reset button
Switch button
Fingerprinting
Open handle
Automatic knob
Keyhole
Lock knob
Emergency
power Mounting
screws
Installation steps
1.Install the lock body, and then fix the lock body with four M5*6
screws.
2.Install the lock cylinder, fix the lock cylinder with the lock
cylinder fixing screw, ensure that the copper bar of the lock
cylinder rotating shaft faces the room, and the length is 18 ~
20mm of the exposed door plane (as shown in Fig. 2, the lock
cylinder must be installed and then the copper bar should be cut)
3.Install the front panel.
4.Install the bottom plate (with rubber pad), and fix the two studs
of the front panel with M5 screws.
5.Connect the front and rear panel data lines, and then install the
rear panel on the hole position, and fix it with four M4 screws
6.Install the lithium battery, cover the battery cover, and complete
the installation steps. Fig.2
Second, Product Introduction
1.Door opening method:Fingerprint, password, IC card, mechanical key, We-chat applet
and many other ways to open the door. Bring you a different experience. (The specific
configuration is subject to the actual product)
2.Fingerprint: Using advanced semiconductor sensor, 360-degree recognition angle, wide
fingerprint collection area, high resolution, effectively preventing fake fingerprints.
3.Password: Adopting fashionable and advanced touch-screen button technology, which can
add 12 irrelevant passwords before and after the correct password, effectively preventing
the embarrassment of entering the password when multiple people are walking together.
4.Two-factor authentication: password, fingerprint, and card can be set to verify and unlock
in pairs. After setting, only two users should verify at the same time to open the door,
suitable for special occasions.
5.User Management: The administrator has the highest authority (ordinary users can only
open and close the door), can set the lock, the number of administrators is 9 (can be
password, fingerprint, card), the total capacity is 300.
6.Alarm function: The machine has anti-pick-lock alarm, low pressure alarm, trial and error
alarm.
7.Backup power supply: When the battery is exhausted, 5V mobile power can be used to
provide emergency power to the door lock.
an
Add administrator
It can be fingerprint, password, IC card.
Under the normal
conditions,
”*”Back / Exit / Delete
After adding, you can enter the
“#”Confirm key / Input
door lock function
key / Repeat voice
management.
broadcast
Press "1" to enter Press "2" to Press "3" to enter Press "4" to enter
the function setting adjust the volume voice settings the time setting
1. Turn on dual
verification 2. Turn 1.Volume up 1. Use Chinese
2.Volume prompt 2. Use Set time
off the anti prying
alarm. 3. Turn on reduction English prompt
mute mode.
According to the actual use needs, select the Press "year, month, day,
hour, minute" to set the
corresponding number key to complete the setting time, press "*" to delete,
and press "#" to confirm
Press "1" to set up the wireless Press "2" to set the door lock function
network
Oblique tongue
Motor direction Lock in place
time
▲ If you input the wrong password for more than 5 times in five
minutes, the keyboard will be locked for 90 seconds. The system
will not respond to any operation within 90 seconds. You can enter
the administrator page through the setting key to release it.
▲When the voltage is lower than 6.9v, the automatic alarm will be
given every time you unlock the door. The rear door lock can be
unlocked for 200 times. If the voltage exceeds 6.9v, it is forbidden to
unlock the door. Please replace the battery before the unlocking
times are reached.
Use we-chat scan to open the we chat
applet for unlocking.(It can only be used
after setting fingerprint lock time and
administrator's digital password)